ELW135 ELW136 ELW4503 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Features • High speed 1Mbit/s • High isolation voltage between input and output (Viso=5000 Vrms ) • Guaranteed performance from 0°C to 70°C • Wide operating temperature range of -55°C to 100°C • Pb free and RoHS compliant • UL approved (No. 214129) • VDE approved (No. 132249) • SEMKO approved • NEMKO approved • DEMKO approved Schematic • FIMKO approved • CSA approved (No. 2037145) Description The ELW135, ELW136 and ELW4503 devices each consist 1 8 1 8 2 7 2 7 3 6 3 6 4 5 4 5 of an infrared emitting diode, optically coupled to a high speed photo detector transistor. A separate connection for the photodiode bias and output-transistor collector increase the speed by several orders of magnitude over conventional phototransistor couplers by reducing the base-collector capacitance of the input transistor. ELW135 / ELW136 ELW4503 The devices are packaged in an 8-pin DIP wide body package and available in wide-lead spacing and SMD Pin Configuration Pin Configuration option. 1. No Connection 1. No Connection 2. Anode 2. Anode 3. Cathode 3. Cathode Applications 4. No Connection 4. No Connection • Line receivers 5. Gnd 5. Gnd • Telecommunication equipments 6. Vout 6. Vout • Power transistor isolation in motor drives 7. VB 7. No Connection • Replacement for low speed phototransistor photo couplers 8. VCC 8. VCC • Feedback loop in switch-mode power supplies • Home appliances • High speed logic ground isolation Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 1 Rev.1 http://www.everlight.com August 2, 2011 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELW135 ELW136 ELW4503 Absolute Maximum Ratings (Ta=25°C) Parameter Input Symbol Rating Unit Forward current IF 25 mA Peak forward current (50% duty, 1ms P.W) IFP 50 mA Peak transient current (≤1µs P.W,300pps) IFtrans 1 A Reverse voltage VR 5 V Power dissipation PIN 45 mW Power dissipation PO 100 mW Emitter-Base reverse voltage ELW135 ELW136 VEBR 5 V Base current ELW135 ELW136 IB 5 mA Average Output current IO(AVG) 8 mA Peak Output current IO(PK) 16 mA Output voltage VO -0.5 to 20 V Supply voltage VCC -0.5 to 30 V VISO 5000 V rms Operating temperature TOPR -55 ~ +100 °C Storage temperature TSTG -55 ~ +125 °C TSOL 260 °C Output Isolation voltage *1 Soldering temperature *2 Notes *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1, 2, 3, 4 are shorted together, and pins 5, 6, 7, 8 are shorted together. *2 For 10 seconds. Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 2 Rev.1 http://www.everlight.com August 2, 2011 ELW135 ELW136 ELW4503 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Electrical Characteristics (TA=0 to 70°C unless specified otherwise) Input Parameter Symbol Min. Typ.* Max. Unit Forward voltage VF - 1.45 1.8 V IF = 16mA Reverse Voltage VR 5.0 - - V IR = 10µA ∆VF/∆TA - -1.9 - mV/°C IF =16mA Symbol Min. Typ.* Max. Unit - 0.001 0.5 - 0.01 1 - - 50 - 110 200 - 0.01 1 - - 2 Temperature coefficient of forward voltage Conditions Output Parameter Logic High Output Current Logic Low Supply Current Logic High Supply Current IOH ICCL ICCH Conditions IF=0mA, VO=VCC=5.5V, TA=25°C µA IF=0mA, VO=VCC=15V, TA=25°C IF=0mA, VO=VCC=15V µA IF=16mA, VO=Open, VCC=15V IF=0mA, VO=Open, VCC=15V, TA=25°C µA IF=0mA, VO=Open, VCC=15V * Typical values at TA = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 3 Rev.1 http://www.everlight.com August 2, 2011 ELW135 ELW136 ELW4503 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Transfer Characteristics (TA=0 to 70°C unless specified otherwise) Parameter Current Transfer Ratio Logic Low Output Voltage Min. Typ.* Max. ELW135 7 - 50 ELW136 ELW4503 19 - 50 5 - - ELW135 Symbol CTR Unit Conditions IF = 16mA ,VO = 0.4V, VCC=4.5V, TA=25°C % IF = 16mA ,VO = 0.5V, VCC=4.5V ELW136 ELW4503 15 - - ELW135 - 0.18 0.4 IF = 16mA ,IO = 1.1mA, VCC=4.5V, TA=25°C ELW136 ELW4503 - 0.25 0.4 IF = 16mA ,IO = 3mA, VCC=4.5V, TA=25°C - - 0.5 - - 0.5 ELW135 VOL ELW136 ELW4503 V IF = 16mA ,IO = 0.8mA, VCC=4.5V IF=16mA ,IO=2.4mA, VCC=4.5V * Typical values at TA = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 4 Rev.1 http://www.everlight.com August 2, 2011 ELW135 ELW136 ELW4503 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Switching Characteristics (TA=0 to 70°C unless specified otherwise, IF=16mA, Vcc=5V) Parameter Propagation Delay Time to Logic Low (Fig.8) Propagation Delay Time to Logic High (Fig.8) Symbol ELW135 TPHL ELW136 ELW4503 ELW135 TPLH ELW136 ELW4503 Common Mode ELW135 Transient Immunity at ELW136 Logic High *3 (Fig.9) ELW4503 Common Mode ELW135 Transient Immunity at ELW136 Logic Low (Fig.9)*3 ELW4503 CMH CML Min. Typ.* Max. Unit Conditions - 0.36 1.5 - - 2.0 - 0.32 0.8 RL=1.9KΩ, TA=25°C - - 1.0 RL=1.9KΩ - 0.45 1.5 RL=4.1KΩ, TA=25°C - - 2.0 RL=4.1KΩ, TA=25°C µs µs RL=4.1KΩ RL=4.1KΩ - 0.25 0.8 RL=1.9KΩ, TA=25°C - - 1.0 RL=1.9KΩ 1,000 - - 1,000 - - 15,000 20,000 1,000 - - 1,000 - - 15,000 20,000 IF = 0mA , VCM=10Vp-p, RL=4.1KΩ, TA =25°C V/µs V/µs IF = 0mA , VCM=10Vp-p, RL=1.9KΩ, TA =25°C IF = 0mA , VCM=1500Vp-p, RL=1.9KΩ, TA =25°C IF = 0mA , VCM=10Vp-p, RL=4.1KΩ, TA =25°C IF = 0mA , VCM=10Vp-p, RL=1.9KΩ, TA =25°C IF = 0mA , VCM=1500Vp-p, RL=1.9KΩ, TA =25°C * Typical values at TA = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 5 Rev.1 http://www.everlight.com August 2, 2011 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELW135 ELW136 ELW4503 Typical Performance Curves Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 6 Rev.1 http://www.everlight.com August 2, 2011 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELW135 ELW136 ELW4503 Figure 8 Switching Time Test Circuit & Waveform Figure 9 Transient Immunity Test Circuit & Waveform Note: *3 Common mode transient immunity in logic high level is the maximum tolerable (positive) dVcm/dt on the leading edge of the common mode pulse signal VCM, to assure that the output will remain in a logic high state (i.e., VO > 2.0V). Common mode transient immunity in logic low level is the maximum tolerable (negative) dVcm/dt on the trailing edge of the common mode pulse signal, VCM, to assure that the output will remain in a logic low state (i.e., VO < 0.8V). Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 7 Rev.1 http://www.everlight.com August 2, 2011 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELW135 ELW136 ELW4503 Order Information Part Number ELW13XY(Z)-V or ELW4503Y(Z)-V Note X = Part No. (X = 5 or 6) Y = Lead form option (S or none) Z = Tape and reel option (TA, TB or none) V = VDE (optional) Option Description Packing quantity None Standard DIP-8 45 units per tube M Wide lead bend (0.4 inch spacing) 45 units per tube S (TA) Surface mount lead form + TA tape & reel option 1000 units per reel S (TB) Surface mount lead form + TB tape & reel option 1000 units per reel Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 8 Rev.1 http://www.everlight.com August 2, 2011 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELW135 ELW136 ELW4503 Package Drawing (Dimensions in mm) Standard DIP Type Option S Type Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 9 Rev.1 http://www.everlight.com August 2, 2011 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELW135 ELW136 ELW4503 Recommended pad layout for surface mount leadform Device Marking EL W136 YWWV EL W4503 YWWV Notes 4503 W136 denotes Device Number Y denotes 1 digit Year code WW denotes 2 digit Week code V denotes VDE (optional) Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 10 Rev.1 http://www.everlight.com August 2, 2011 ELW135 ELW136 ELW4503 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions Dimension No. A B Do D1 E F Dimension(mm) 14±0.1 13±0.1 1.5±0.1 1.5±0.1 1.75±0.1 7.5±0.1 Dimension No. Po P1 P2 t W K Dimension(mm) 4.0±0.1 12.0±0.1 2.0±0.1 0.4±0.1 Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 11 Rev.1 16.0+0.3/ -0.1 4.5±0.1 http://www.everlight.com August 2, 2011 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELW135 ELW136 ELW4503 Solder Reflow Temperature Profile 260 °C (peak,10 Sec Max) >255 °C ( 30s Max ) 217°° C 1-3 °C/Sec Max 200°° 60 – 100 Sec 150°°C 60 – 150 Sec 1-3 °C/Sec Max TIME (S) Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 12 Rev.1 http://www.everlight.com August 2, 2011 8 PIN DIP WIDE BODY HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELW135 ELW136 ELW4503 DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. Everlight Electronics Co., Ltd. Document No DPC-0000108 ： 13 Rev.1 http://www.everlight.com August 2, 2011