3 2 0 Wa t t M e d i c a l Grade Switching Power Supply with PFC PMMK320E series 320 Watts Output Power Single Outputs Universal 90-264VAC Input 5VDC to 48VDC Outputs 5656VDC Input to Output Isolation Active Power Factor Correction 3.86”W x 8.03”L x 1.57”H Model Number Output Voltage Output Amps (max) Ripple & Noise max. Efficiency SINGLE OUTPUT PMMK320S-5E PMMK320S-12E PMMK320S-15E PMMK320S-24E PMMK320S-36E PMMK320S-48E 5 VDC 12 VDC 15 VDC 24 VDC 36 VDC 48 VDC 60 26.7 21.4 13.4 8.9 6.7 71% 77% 79% 79% 81% 81% Astrodyne products are not authorized or warranteed for use as critical components in life support systems, equipment used in hazardous environments, nuclear controls systems, or other mission-critical applications. WWW.ASTRODYNE.COM 100mV pk-pk 120mV pk-pk 150mV pk-pk 150mV pk-pk 150mV pk-pk 150mV pk-pk All specifications are typical at nominal input, full load, and 25°C unless otherwise noted ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 3 2 0 Wa t t M e d i c a l Grade Switching Power Supply with PFC 90-264 VAC; Nom: 100-240VAC 47-63 Hz 0.95, min. Nom I/P, FL 30A @ 115VAC Cold Start, FL* 60A @ 230VAC Cold Start, FL* 5.4 Amps max., 90V I/P 1.8 Amps max., 264V I/P <0.3mA, 240Vin, 50Hz Isolation (Note 2) Insulation Resistance Efficiency (FL. Nom I/P) Safety UL/cUL: UL-EU: CB: CE: See Selection Chart ±1%, max. ±1~1.5%, max. ±1%, typ (2% 5 Vout) See Selection Chart 130% max. Auto Recovery * 160% max. Auto Recovery * Auto Recover after fault condition is removed * <4S <25mS, typ (Nom I/P, FL) 20mS, typ (Nom I/P, FL) <10% of Nominal Output Compensates for up to 0.5V drop Open Collector, Logic “1” = ON “0” = Off. No Termination necessary to maintain constant “On” operation ENVIRONMENTAL SPECIFICATIONS OUTPUT SPECIFICATIONS Voltage and Current Line Regulation (LL-HL) Load Regulation 10%-FL Preset Accuracy (Note 3) Ripple/Noise (Notes 1, & 4) Over Voltage Protection Over Current Protection Short Circuit Protection Turn On Delay Time Rise Time Hold Up Time Over-Shoot/Under Shoot Remote Sense Remote Shutdown PHYSICAL SPECIFICATIONS Size Construction Weight series GENERAL SPECIFICATIONS INPUT SPECIFICATIONS Input Voltage Range Frequency Range Power Factor Correction Inrush Current, typ: Input Current Leakage Current PMMK320E 8.03”(L) x 3.86”(W) x 1.57”(H) Enclosed 1.75 lb, (794g) * These are stress ratings. Exposure of the devices to any of these conditions may adversely affect long term reliability. Proper operation under conditions other than the standard operating conditions is neither warranteed nor implied. WWW.ASTRODYNE.COM I/P-O/P: 5656VDC I/P-Ground: 2121VDC O/P-Ground: 707VDC ≥20MΩ See Selection Chart ANSI/AAMI ES60601-1 3rd ed. CSA C22.2 No. 60601-1 3rd ed. EN60601-1 3rd ed. IEC60601-1 3rd ed. EN60601-1-2 Oper. Temperature -20 to +70°C (See Derate Curve) Storage Temperature -25 to +85°C * Relative Humidity 10% to +90%, * Storage: 5-95% EMS Harmonics Class D, 61000-3-2 Fluctuations 61000-3-3 ESD 61000-4-2 RS 61000-4-3 EFT 61000-4-4 Surge 61000-4-5 CS 61000-4-6 MS 61000-4-8 DIPS 61000-4-11 EMI EN55022 Class B MTBF Mil Std 217F, 25°C 65,000 Hrs, min. Vibration 4G Peak, 50-500Hz, 3 Axes Drop Test 70 CM NOTES 1. All measurements should be made directly at the terminals of the power supply 2. Isolation for up to 1 minute duration. 3. Preset Accuracy measured at nominal load, 120VAC input. 4. O/P Noise measured directly at the pins/terminals at nominal load, 0.1uF ceramic bypass and 47uF electrolytic, pk-pk @ 20MHz bandwidth. ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 PMMK320E 3 2 0 Wa t t M e d i c a l Grade Switching Power Supply with PFC series MECHANICAL DIMENSIONS 2.00 50.8 M3 hole size .93 23.6 .50 12.7 5.95 151.1 .94 23.9 4.33 110 1.57 40 .83 21 1.50 38 7.01 178 FG ACN ACL +Vo(5V) COM COM COM +Vo +Vo 3.86 98 -S +S S/D GND 8.03 203.9 UNITS:mm (in) WWW.ASTRODYNE.COM PROPRIETARY AND CONFIDENTIAL THE INFORMATION CONTAINED IN THIS DRAWING IS THE SOLE PROPERTY OF DIMENSIONS ARE IN INCHES TOLERANCES: FRACTIONAL ANGULAR: MACH BEND TWO PLACE DECIMAL THREE PLACE DECIMAL MATERIAL NAME DRAWN CHECKED ENG APPR. MFG APPR. Q.A. COMMENTS: DATE ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 PMMK320E ASTRODYNE PACIFIC CORP ELECTRICAL SPECIFICATION N NEE PPAACCIIFSwitching FIICC CCO ORRPP Power Supply with PFCEELLEECCTTRRIICCAALL SSPPEECCIIFFIICCAATTIIO ON N 3 2 0 Wa t t MAeASSdTTiRRcOO aDDl YYGrade 7. Derating OUTPUT DERATING CURVE series Curve 120% Load(%) 100% 80% 60% 40% 20% 0% -20℃ -10℃ ℃ 10℃ 20℃ 30℃ 40℃ 50℃ 60℃ 70℃ Ambient (℃) Input voltage (VAC) 60Hz Ta=25℃ 1. 5V 2. 12、15、24、36、48V WWW.ASTRODYNE.COM 1313 ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458