KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV 56-SDIP-600 I2C BUS NTSC 1 CHIP FOR COLOR TV The KA2163 is a monolithic integrated circuit for VIF, SIF, chroma and deflection circuit of NTSC color TV. The KA2163 also provides audio / video switch and OSD interface. It combines these functions in a 56 SDIP package and the KA2163B also includes I2C bus control functions for automatically adjustment. FUNCTIONS - VIF/SIF - Video - Chroma - Deflection - OSD interface - I2C bus circuit ORDERING INFORMATION Device Package Operating Temperature KA2163 56 -SDIP -20¡É ~ +65¡É FEATURES VIF CIRCUIT - PLL type IF demodulation (bus alignment) - Adjustment free AFT without tank coil - RF AGC output (delay point : bus alignment) - Dual time constant fast AGC OSD CIRCUIT SIF CIRCUIT DEFLECTION CIRCUIT - Inter carrier SIF system - External sound select switch (bus select) - Attenuator circuit - Auto-slicer type high performance - Sync. separator circuit - Adjustment free countdown system - Sync. separation output - X-ray protect circuit - Vertical ramp output - Dual time constant AFC circuit - Horizontal and Vertical position bus adjustment - Vertical amplitude adjustment (bus adjustment) VIDEO CIRCUIT - Black stretcher - DC Restoration circuit - D.L aperture compensate circuit (bus control) - Internal filter auto-adjust circuit (fsc link type) - Uni-color circuit(bus control) - Y delay line circuit - Linear RGB input - Cut off / Drive adjustment (bus adjustment) - RGB primary color output CHROMA CIRCUIT - Color control circuit (bus control) - Tint control circuit 1 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 2 47 SIF VCC 48 PIF TANK 49 PIF TANK 50 SIF GND 51 LIMITER IN 52 AUDIO TV IN 53 DE-EMPHASIS 54 EXT. AUDIO 55 EXT. AUDIO 56 Smoothing 3.58 Trap DC Restoretion Black Streatch WPS Clamp AFT BPF I DET VCC LOCK DET VCO 90¡£ SIF VCC Limier ATT ATT FM DET SIF GND M/M-97-D008 97-05-20 V SEPA FILTER 24 V. RAMP 23 NFB 22 V. OUT 21 B OUT 20 G OUT 19 R OUT 18 D. VCC 17 ANALOG B IN 16 ANALOG R IN 15 ANALOG R IN 14 F-BLK 13 GND 12 VCXO 11 APC FILTER 10 LOOP FILTER H.VCC 9.0V TV DET. OUT 25 D.VCC 3.3V 46 H. VCC GND VCC 26 PIF VCC 45 PIF GND CHROMA IN Bus Interface 44 SCL V.RAMP AFT 27 Cut-off/drive 43 SDA Analogue RGB Y IN VCXO 42 MTX DC REST RF AGC 41 VC/D AV/SW OUT V SEPA 40 Bright BLACK DET APC 39 28 SW EXT. VIDEO LPF 38 TINT ACL Killer 37 AGC DET TV IN H SEPA 36 WPL ABL DEMO 35 Color D. GND HC/D 34 Contrast 32fHVCO Y-DL 33 ACC H. AFC Q DET 32 AFC-2 H. OUT AFC-1 31 32fH VCO Sync. OUT Sharpness 30 X2 FBP IN X-RAY 29 H. OUT X-RAY H.RAM BLOCK DIAGRAM 9 PIF VCC 8 PIF IN 7 PIF IN 6 PIF GND 5 AGC FILTER 4 SIF TANK 3 RF AGC 2 SOUND OUT 1 SOUND OUT I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 TERMINAL FUNCTION PIN NO. 1 2 PIN NAME Sound Output FUNCTION This terminal is for Sound Output. The maximum flew out current of these terminals is 3.6mA. So, the minimum load resister is 1k¥Ø . INTERFACE CIRCUIT 48 3k¥ 500¥ 2 200¥ Attenuator 34.5k¥ 330¥ìA 3k¥Ø 4.5V 51 9 500¥ 3 RF AGC This terminal is for RF AGC output. 43k¥Ø 300¥ 3 30k¥Ø Monitor 30k¥Ø 6 4 SIF Tank Coil This terminal is for connecting SIF detect tank coil. This terminal is for Sound Mute Switch, too. If this terminal is connected to GND, the sound output is muted. 48 5.5PF 4 42¥Ø 100¥ 500¥ìA 51 9 200¥ìA 5 AGC Filter This terminal is for PIF 2nd AGC filter. 50¥Ø 20k¥Ø 5 50¥ìA RF AGC 100PF AGC Amplifier 6 6 PIF GND This terminal is for GND of PIF circuit. 9 100k¥Ø 7 8 PIF Input This terminal is for IF input. The typical input value is 90dB¥ìV. 7 20pF 20pF 8 1.2k¥Ø 2V 1.2k¥Ø 140¥Ø 700¥Ø 700¥Ø 6 3 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 PIN NO. 9 PIN NAME PIF Vcc FUNCTION INTERFACE CIRCUIT This terminal is for Vcc of PIF circuit. 48 10 Loop Filter This terminal is for PIF PLL loop filter. APC Detection 500¥Ø 10 51 46 11 APC Filter 500¥Ø 500¥Ø This terminal is for APC filter of fsc oscillation. 300¥Ø 11 5k¥Ø 300¥Ø Killer 13 46 12 VCXO This terminal is for X’tal of 3.58MHz VCXO. 2.5k¥Ø 2.5k¥Ø 12 2.5k¥Ø 500¥Ø 1.5pF 500¥Ø 14k¥Ø 13 13 GND This terminal is for V/C/D GND. 46 14 Fast Blanking 7.5¥ìA This terminal is for fast blanking of RGB input. 7.5¥ìA 800¥Ø 14 1V 13 4 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 PIN NO. PIN NAME FUNCTION INTERFACE CIRCUIT 46 5k¥Ø 5k¥Ø 15 16 17 Analog RGB Input 2k¥Ø These terminals are for RGB signal input. 15 16 17 2k¥Ø 2k¥Ø 75¥ìA 22.5¥ìA 13 18 Digital Vcc This terminal is for Vcc of digital curcuit. 46 150¥Ø 400¥Ø RGB Output This terminal is for RGB primary color signal output. 19 20 21 BLK 1mA 19 20 21 150¥Ø 13 46 100¥ 22 Vertical Output This terminal is for vertical pulse output. 50¥Ø 22 10k¥Ø 13 46 150¥Ø 23 24 NFB, Vertical Ramp. These terminals are for NFB input and vertical ramp output. 5k¥Ø 5k¥Ø 5k¥Ø 5k¥Ø 13 24 1.1k¥Ø 1.1k¥Ø 100¥ìA 13 2.8V 50¥ìA 5 M/M-97-D008 97-05-20 RGB Blanking I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 PIN NO. PIN NAME FUNCTION INTERFACE CIRCUIT 46 12.5¥ìA 100¥Ø 25 Vertical Sync. Separation Filter This terminal is for vertical sync. separation filter. 25 400¥Ø 3k¥Ø 150¥ìA 5k¥ 13 26 H. Vcc This terminal is for Vcc of horizontal circuit 50¥ìA SCL, SDA These terminals are for input and output of I2C Bus. 50¥ìA SCA 1K¥Ø SDA 100¥Ø 27 28 SDA Only 3.25V 27 28 35 30 X-RAY Fly-back Pulse Input This terminal is for Fly-back pulse input. The Fly-back pulse is the reference of AFC circuit, gate pulse and so on. The current needs to keep under 1mA. 26 5k¥Ø 5k¥Ø 5k¥Ø 1k¥ 29 100¥ìA 3.5V 13 26 200¥Ø HV 30 1.4V 29 This terminal is for input of X-RAY protect signal.The threshold voltage is 3.5V (Typ.). If applied voltage is more than threshold voltage, the X-RAY protect circuit will make horizontal output a low. 152k¥ 13 26 31 Sync. Pulse Output This terminal is for Sync. pulse output. 30k¥Ø 13 6 M/M-97-D008 97-05-20 1k¥Ø 31 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 PIN NO. PIN NAME FUNCTION INTERFACE CIRCUIT 32 Horizontal Output 2pF 26 This terminal is for horizontal pulse output. 1k¥Ø 1k¥Ø 50¥Ø 32 13 33 34 H. AFC 32fH VCO This terminal is for horizontal AFC filter. The AFC circuit fits the phase between inputed horizontal sync. signal and horizontal pulse which is made by countdown 32fH. This terminal is for connecting ceramic oscillator. That constitutes 32fH (503kHz) oscillation circuit. The CSB503F30 (Murata) is recommended. 26 H C.D Input 33 Sync. 13 26 10k¥Ø 1k¥Ø 1k¥Ø D. GND 3k¥Ø 34 10k¥Ø 15¥ìA 600¥ìA 13 35 32fH VCO This terminal is for GND of digital circuit. 46 1k¥Ø A.B.L This terminal is for A.B.L circuit. 10k¥Ø 36 1k¥Ø 100¥ìA 100¥ìA 10k¥ 100¥ìA 3.4V 36 13 46 37 TV Input This terminal is for input of PIF detected signal. The typical input amplitude is 1.0Vp-p. 37 13 7 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 PIN NO. PIN NAME FUNCTION INTERFACE CIRCUIT 46 A.C.L This terminal is for ACL circuit 1k¥Ø 38 10k¥Ø 1k¥Ø 10k¥Ø 100¥ìA 100¥ìA 100¥ìA 3.4V 38 13 46 39 External Video Input This terminal is for input of external video signal. 39 13 46 40 Black Peak Detection This terminal is for filter of black peak detection. 3.3k¥Ø 1.8k¥Ø 1k¥Ø 40 8k¥Ø 1k¥Ø 2.8k¥Ø 13 41 Video Switch Output This terminal is for output of video switch which selects TV signal or external video. Amplifier Gain is (Min.) 1.7 (Typ.) 1.9, (Max.) 2.1 . 46 100¥Ø 200¥ 50¥ 41 75¥ìA 13 46 2.5k¥ 42 D.C. Restoration This terminal is for filter of APL detection. 2.5k¥Ø 42 2k¥Ø 3k¥Ø 13 8 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 PIN NO. PIN NAME FUNCTION INTERFACE CIRCUIT 46 3k¥Ø 43 Y Input This terminal is for Y signal input. The typical input amplitude is 1.0Vp-p. 3k¥Ø 1.5k¥Ø 43 1.5k¥Ø 150¥ìA 150¥ìA 13 This terminal is for AFT output. Monitor signal output mode can be selected via Bus. A.F.T. B0 B1 0 0 0 1 TEST purpose only 1 0 B 1 45 Chroma lnput 46 V / C / D Vcc 47 TV Detection Output 1 1k¥Ø RFAGC/2 200¥Ø OUTPUT AFT 5k¥Ø 100¥Ø X1 44 B 70k¥Ø 2k¥Ø 4.1V 44 48 1k¥Ø 180k¥Ø 2k¥Ø 51 RF AGC/2 This terminal is for chrominance signal input. The typical input signal amplitude is 286mVp-p (at burst signal). This IC is to go to test mode with this terminal voltage higher than 4.5V. 46 120k¥Ø 40pF 45 1k¥Ø 120k¥Ø 30k¥Ø 30k¥Ø Killer 20k¥Ø 13 This terminal is for Vcc of video, Chroma and Deflection circuit. 48 This terminal is for PIF detected signal output. 200k¥Ø 15k¥Ø 40k¥Ø 1k¥Ø 47 2k¥Ø 500¥ìA 2pF 51 48 9 S.I.F. Vcc This terminal is for Vcc of SIF circuit. M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 PIN NO. PIN NAME FUNCTION INTERFACE CIRCUIT 600¥ 49 500¥ 600¥ 2k¥Ø 1k¥ 500¥ 50 2k¥Ø P.I.F. Tank Coil 1k¥ 49 50 600¥ 48 These terminals are for connecting a tank coil of PIF detection circuit. TOKO Corp. products 292GJAS-7475BS(45.75MHz), 292GJAS-7476BS (58.75MHz) are recommended. 51 51 S.I.F. GND This terminal is for GND of SIF circuit. 48 10pF This terminal is for input of SIF limiter amplifier circuit. 52 20k¥Ø 23k¥Ø Limiter lnput 3V 52 4.5k¥ 200¥ìA 51 53 TV Audio Signal Input This terminal is for input of SIF detected signal. This terminal is connected to pin 54 via capacitor. 48 200¥ 53 30k¥ Audio Switch 3V 50¥ìA 51 48 This terminal for filter of SIF de-emphasis. 200¥ 53 4.5V 10pF De-emphasis 30k¥ 54 51 48 55 56 External Audio Input These terminals are for external audio input. 23.5k¥ 55 23.5k¥ 3V 10 M/M-97-D008 97-05-20 Audio Switch 50¥ìA 51 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 Slave address : 88H SUB ADDRESS D7 D6 00 Trap Color 0000 0000 01 C.Filter Tint 1100 0000 02 A. SW Brightnes 0000 0000 03 BLK Uni-color 0000 0000 0110 0000 0001 0000 04 Mute 05 Vertical Phase D5 D4 D3 D2 Sharpness Horizontal Phase D1 D0 PRESET 06 B0 B1 Audio Attenuator 0000 0000 07 B2 B3 DON’T USE (Fix on 100000) 0010 0000 08 B4 V. SW RF AGC 0000 0000 09 AFC WPL Vertical Amplitude 0010 0000 0A V.Fixed 0100 0000 PIF VCO 0B R Cut OFF 0000 0000 0C G Cut OFF 0000 0000 0D B Cut Off 0000 0000 0E R Gain 0000 0000 0F B Gain 0000 0000 FUNCTION RANGE (MIN. ~ MAX.) DEFAULT Color -60 ~ 0dB TINT ¡¾ 42¡£ Brightness 1.34 ~ 2.6 ~ 3.86V 1.34V Uni-Color -24 ~ 0dB -24dB Sharpness -18 ~ 6dB ~ 14dB (4MHz Gain) Audio ATT -85 ~ 6dB RF AGC 65dB¥ì ~ 105d¥ìV (0.6dB / bit), 000000 : IF Mute IF Mute Ver. Amplitude 1.6 ~ 2.4V Center PIF VCO ¡¾ 2.2MHz (35kHz / bit) Center RGB Cut-off -0.4 ~ 0.4V -0.4V RB Gain -3.1 ~ 3.1dB -3.1dB 11 -60dB 0¡£ 6dB -85dB M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 FUNCTION RANGE (MIN. ~ MAX.) DEFAULT 3.58 Trap ( 0 ) : On / ( 1 ) : Off On Chroma Filter ( 0 ) : Band Pass Filter / (1) : Take Off Filter A, V SW ( 0 ) : TV Mode / (1) : EXT. Mode TV BLK ( 0 ) : BLK On / (1) : BLK Off On MUTE (00) : Off / (01) : Y MUTE / (10) : Hout Stop / (11) : Y MUTE + V Stop (01) H. AFC ( 0 ) : AFC2 Normal / (1) : AFC2 x 3 (0) WPL ( 0 ) : On / (1) : Off Off V. Fixed Mode ( 0 ) : Normal / (1) : V Frequency 60Hz Fix Normal B0, B1 (Monitor) Pin 44’s output is selectable. (00) : AFT Voltage / (01) : Test Mode / (10) : Blue Output / (11) : Half of RF AGC Voltage AFT Voltage B2, B3, B4 (Test Mode) Bits for Test Mode. Use this IC with these bits (000). TOF (000) Read Mode D7 D6 D5 D4 D3 D2 D1 D0 POR AFT IF Lock AFT - V Lock H Lock X-RAY FUNCTION CONTENTS POR (Power On Reset) ( 0 ) : SECOND / ( 1 ) : FIRST AFT Refer to Following Figure IF LOCK ( 0 ) : LOCK OUT / ( 1 ) : LOCK IN V LOCK ( 0 ) : LOCK IN / ( 1 ) : LOCK OUT Det. Window : 262H ~ 263H H LOCK ( 0 ) : LOCK OUT / ( 1 ) : LOCK IN This function is forced to unlock at Vp, so data is valid after 50H. X-RAY ( 0 ) : X-RAY OFF / ( 1 ) : X-RAY ON ¡Û Vertical Phase (3bit) This mode is for changing vertical output timing. (Vertical picture position is changed 0 ~ 7H as right Table.) ¡Û Horizontal Phase (5bit) This mode is for changing horizontal picture position. Horizontal output phase is changed ¡¾ 3¥ìs as maximum. ¡Û AFT Read Bus 3.3V 1.7V AFT D6 D4 12 M/M-97-D008 97-05-20 D7 D6 D5 MODE 0 0 0 Reference 0 0 1 1H Delay 0 1 0 2H Delay 0 1 1 3H Delay 1 0 0 4H Delay 1 0 1 5H Delay 1 1 0 6H Delay 1 1 1 7H Delay I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 I2C BUS CONTROLLED FORMAT SUMMARY Bus controlled format of KA2163B is based on I2C Bus Control format of Philips. Data Transfer Format S Slave address 0 A Sub address A Data 8 bit 7 bit MSB A P 8 bit MSB S : Start Condition P : Stop Condition A : Acknowledge (1) Start and Stop Condition (2) Bit Transfer SDA SDA SCL SCL S P Start Condition Stop Condition SDA cannot change. SDA can change. (3) Acknowledge (4) Slave Address from Master SDA High lmpedance from Slave SDA from Master SCL A6 A5 A4 A3 A2 A1 A0 R/W 1 0 0 0 1 0 0 0 High lmpedance S 1 8 9 Purchase of SAMSUNG I2C components conveys a license under the Philips Iicense under the Philips I2C Patent Rights to use these components in an I2C system, provided that the system conforms to the I2C Standard Specification as defined by Philips. 13 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 MAXIMUM RATING (Ta = 25¡É ) CHARACTERISTIC SYMBOL RATING UNIT Vcc 12 V PDmax 2.19 (Note1) W Input Terminal Voltage Vin GND - 0.3 ~ Vcc + 0.3 V Input Signal Amplitude ein 4 Vp-p Operating Temperature Topr -20 ~ 65 ¡É Storage Temperature Tstg -55 ~ 150 ¡É Power Supply Voltage Power Dissipation (Note 1) When using the device at above Ta = 25¡É , decrease the power dissipation by 17.5mW for each increase of 1¡É . (Note 2) As this IC is weak in a surge voltage, handle it with care from being damage. RECOMMENDED OPERATING CONDITION CHARACTERISTIC SYMBOL MIN. TYP. MAX. UNIT REMARKS PIF Power Supply Voltage VCCP 8.5 9.0 9.5 V - SIF Power Supply Voltage Vccs 8.5 9.0 9.5 V - V/C/D Power Supply Voltage Vccv 8.5 9.0 9.5 V - H.Vcc Power Supply Voltage H.Vcc 8.5 9.0 9.5 V - D.Vcc Power Supply Voltage D.VCC 2.7 3.3 3.8 V - TV External Video Input Level Vin37/39 - 1.0 - Vp-p including sync. Standard Video Input Level Vin43 - 1.0 - Vp-p including sync. Standard Chroma Input Level Vin45 - 286 - mVp-p at burst signal FBP Width TFBP 10 12 - ¥ìs Vth = 1.4V, Vcc - 1.4V FBP Input Flow in Current IFBPmax - - 2 mA - PIF Output Load Resister ROP 2 8.2 - k¥Ø - SIF Output Load Resister ROS 1 8.2 - k¥Ø - RGB Output Load Resister RORGB - 1.8 - k¥Ø - Horizontal Output Load Resistor RHOUT 330 800 - ¥Ø maximum 10mA Vertical Output Load Resister RVOUT 4.1 5.7 - k¥Ø - Sync. Separation Output Flow In Current Isyncmax - - 1 mA - 14 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 ELECTRICAL CHARACTERISTICS DC CHARACTERISTICS (Unless Otherwise Specified, V CC = 9V, Ta = 25¡É ) PIN No. CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP. MAX. UNIT 2 Sound Output V2 - 3.20 3.70 4.20 V 3 RF AGC V3 - - 0.00 0.50 V 4 SIF TANK V4 - - - - V 5 AGC Filter V5 - 7.00 7.50 8.00 V 6 PIF GND GND - - 0.00 - V 7 PIF Input V7 - 1.50 2.00 2.50 V 8 PIF Input V8 - - 0.00 0.50 V 9 PIF Vcc VCC - - 9.00 - V 10 Loop Filter V10 - - 4.50 - V 11 APC Filter V11 - 6.00 6.50 7.00 V 12 VCXO V12 - 5.30 5.80 6.30 V 13 V/C/D GND GND - - 0.00 - V 14 F-BLK V14 - - 0.00 - V 15 Analog R Input V15 - 4.40 4.90 5.40 V 16 Analog G Input V16 - 4.40 4.90 5.40 V 17 Analog B Input V17 - 4.40 4.90 5.40 V 18 D.Vcc VCC - - 3.30 - V 19 R Output V19 BRT, C. O Cent 2.40 2.70 2.90 V 20 G Output V20 BRT, C. O Cent 2.40 2.70 2.90 V 21 B Output V21 BRT, C. O Cent 2.40 2.70 2.90 V 22 V out V22 - - - - 23 NFB V23 - - - - 24 V. Ramp V24 - - - - 25 V SEPA V25 - 5.80 6.30 6.80 V 26 H. VCC V26 - - 9.00 - V 27 SCL V27 - 4.50 5.00 5.50 V 28 SDA V28 - 4.50 5.00 5.50 V 29 X-RAY V29 - - 0.00 - V 30 FBP Input V30 - - - - - 31 Sync. Output V31 - - - - - 32 H. Output V32 - - - - - 33 H. AFC V33 - 7.00 7.50 8.00 V 34 32fH VCO V34 - 5.50 6.00 6.50 V 35 D. GND - 0.00 - V 36 ABL V36 2.90 3.40 3.90 V 37 TV Input V37 2.90 3.00 3.90 V 38 ACL V38 2.90 3.40 3.90 V 15 - GND BRT, COL Cent BRT, COL Cent M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 PIN NO. CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP. MAX UNIT 39 EXT. Video Input V39 - 1.10 1.60 2.10 V 40 Black DET V40 - 6.10 6.60 7.10 V 41 AV/SW Output V41 - 1.80 2.30 2.80 V 42 DC Rest V42 - 5.50 6.00 6.50 V 43 Y Input V43 - 4.00 4.50 5.00 V 44 AFT V44 - 2.00 2.50 3.00 V 45 Chroma Input V45 - 1.60 1.85 2.10 V 46 V / C / D Vcc V46 - - 9.00 - V 47 TV DET. Output V47 - 4.70 5.20 5.70 V 48 SIF Vcc V48 - - 9.00 - V 49 PIF Tank V49 - - - - V 50 PIF Tank V50 - - - - V 51 SIF GND Vcc - - 0.00 - V 52 Limiter Input V52 - - 0.00 0.50 V 53 Audio TV Input V53 - 2.50 3.00 3.50 V 54 De-emphasis V54 Pin4 GND 4.00 4.50 5.00 V 55 EXT. Audio Input V55 - 2.50 3.00 3.50 V Current Consumption CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP. MAX. UNIT IF Power Supply Current Icci - 32.8 46 52.0 mA V/C/D Power Supply Current Iccv - 52.7 71 76.8 mA H.Vcc Power Supply Current Icch - 10.7 14 18.4 mA D.Vcc Power Supply Current Iccd - 5.2 10 11.6 mA 16 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 AC CHARACTERISTICS ( Unless Otherwise Specified, Vcc = 9V, Ta = 25¡É ) PIF CHARACTERISTIC SYMBOL TEST CONDITION V01 MIN TYP MAX 1.7 2.0 2.3 2.0 2.5 3.0 - 42 - 100 107 - Note 1 Video Detected Output level V02 VIN MIN Vp-p Note 2 Input Sensitivity VIN MAX UNIT dB¥ìV Sync Tip Level VSYNC Note 3 2.6 2.9 3.2 V Output Level For No Input VIF Note 4 4.8 5.2 5.6 V Differential Gain DG - 2 5 % - 2 5 ¡£ 5 7 - MHz 50 55 - 50 55 - - 1.5 - k¥Ø - 3.8 - pF Differential Phase DP PIF Output Frequency Characteristic fC Carrier Wave Compression Ratio CR 2nd Harmonics Compression Ratio HR PIF Input Resistance RiPIF Note 5 Note 6 Note 7 dB Note 8 PIF Input Capacitance CiPIF S/N S/N Note 9 52 55 - dB 920kHz Beat I920 Note 10 42 45 - dB IF AGC Range RWAGC Note 11 61 65 69 dB 4.2 4.5 4.8 7.4 7.6 - - 3.8 - 7.7 8.2 - - 0 0.5 V5MEAN IF AGC Voltage V5MAX Note 12 V5MIN V3MAX RF AGC Voltage Note 13 V3MIN V V RF AGC Control Range ¥ ÄGRFAGC Note 14 35 40 - dB AFT Center Voltage V4CENT Note 15 2.2 2.5 2.8 V 4.4 4.8 - - 0.2 0.5 V4MAX AFT Voltage Note 16 V4MIN V AFT Sensitivity ¥ìAFT Note 17 - 40 - kHz/V AFT Output Resistance RAFTOUT Note 18 40 50 60 k¥Ø PIF VCO Control Sensitivity ¥âIFVCO Note 19 2.0 2.5 - MHz/V 1.0 1.5 - 1.0 1.5 - - 4.4 - fph PIF VCO Pull-in Range PIF VCO Control Range 17 Note 20 fPI ¥ ÄfPIFVCO Note 21 M/M-97-D008 97-05-20 MHz MHz I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 SIF CHARACTERISTIC SYMBOL TEST CONDITION VAAC Sound Output Level VADC MIN. TYP . MAX. UNIT 400 500 600 mVrms - 4.5 - V Note 22 Sound Distortion VAUDIO Note 23 - 0.3 1.0 % AMR AMR Note 24 50 60 - dB Limiting Sensitivity VLIM Note 25 - 35 - dB¥ìV Sound Output Frequency Characteristics fAUDIOH - 130 - - -130 - 24 30 36 -2.0 0.0 2.0 4.0 6.0 8.0 -16 -12 -9 -99 -85 - - - 50 mV 3.2 3.7 4.2 V - 30 - - 47 - fAUDIOL Sound Output Resistance RSOUT Note 26 Note 27 kHz k¥Ø ATT GATTMAXE GATTMAXT ATT Gain GATTMEAN Note 28 GATTMIN V1VAR DC Voltage Drift V1DC Note 29 Ri53 Input Impedance Ri55 Note 30 dB k¥Ø Video Input Impedance Ri41 Note 31 100 - - k¥Ø Input Dynamic Range Vdi41 Note 32 1.0 1.2 1.5 V Video Total Gain GY Note 33 4.5 5.0 - Video Frequency Characteristic fY Note 34 6.0 7.0 - MHz Maximum Output Vdo1 Note 35 7.5 8.0 - V Blackexpanion Amp. Gain GBAMP 1.18 1.43 1.68 40 50 60 IRE 100 103 105 % 1 4 7 9 12 15 - -18 -15 - 125 - 4.5 6 7.5 22.5 24 28.5 Black Expansion Start Point GBSTP Dc Restoration TDC Note 36 Note 37 GSHcent Sharpness Control Characteristics GSHmax Note 38 GSHmin Sharpness Delay Time tSHDLY Cnotrast Control Characteristics GCNcent H. V - BLK Output Voltage VBLK Note 41 - 0.7 1.0 V V-BLK Width TVBLK Note 42 - 3.5~24 - H fSC Trap Gain GTRAP Note 43 - -28 -20 dB 18 GCNmin Note 39 dB Note 40 M/M-97-D008 97-05-20 ns dB I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 OSD CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP. MAX. UNIT Note 44 0.7 1.0 1.3 V - 15 30 - 5 10 Osd Switching Voltage VthOSD Osd Delay Time tOSDDLY Osd Delay Time Difference tOSDD Osd Rising Time ¥óR - 15 30 OSD Falling Time ¥óF - 15 30 Input Clamp Voltage VOSDC Note 46 4.4 4.9 5.4 V OSD Gain GOSD Note 47 1.8 2.0 2.2 V Input Dynamic Range VdiOSD Note 48 2.0 2.2 2.4 V Note 45 ns Cutoff Drive VBRTmax Brightness Control Characteristics VBRTcen Brightness Control Difference Between 3Axes ¥ÄVRGB VBRTmin 3.6 4.0 4.3 2.4 2.7 3.0 1.0 1.4 1.7 -50 0 50 0.5 0.65 0.8 - 0.00 - -0.8 -0.65 -0.5 3.75 4.25 4.75 -4.0 -3.5 -3.0 dB V Note 49 Note 50 Vcutmax Cutoff Control Characteristics Vcutcen Vcutmin Note 51 Gdrvmax Drive Control Characteristics Chroma Input Dynamic Range Gdrvmin Vdi45 Note 52 Note 53 ea ACC Characteristic eb A Note 54 0.95 1.5 1.7 -23 -20 -17 3 6 9 0.9 1.0 1.1 V mV V dB Killer Point EK Note 55 -48 -46 -43 dB VCXO Frequency Control Range ¥ Ä fVCXO Note 56 ¡¾ 50 0 ¡¾ 60 0 - Hz VCXO Frequency Control Sensitivity ¥âVCXO Note 57 - 1.0 - Hz/mV VCXO Pull-in Range fVCXOPL Note 58 ¡¾ 30 0 ¡¾ 45 0 - Hz 0.80 0.84 0.90 0.25 0.29 0.33 101 108 115 G-B 236 243 250 ECR - 20 40 - 20 40 - 20 40 R/B Demodulate Relative Gain G/B R-B Demodulate Relative Phase Carrier Wave Remain 19 ECB ECG Note 59 Note 60 M/M-97-D008 97-05-20 ¡£ mVp-p I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 CHARACTERISTIC SYMBOL TEST CONDITION VCLRmax Color Control Characteristic GCLRcen Note 61 GCLRmin Uni-color Control Characteristic GUNIcen Note 62 GUNImin ¥ÈTNTcen TINT Control Characteristic Video Chroma Delay Time Note 63 ¥Ä ¥ÈTNT tV - C Note 64 MIN. TYP . MAX. UNIT 3.9 4.1 4.3 Vp-p 4.5 6 7.5 38 40 - 4.5 6 7.5 22 24 26 -7 0 7 ¡¾ 3 5 ¡¾ 4 5 ¡¾ 55 -30 0 30 dB dB ¡£ ns Deflection Horizontal Free Run Freq. fH Note 65 -100 0 100 Hz H. Out Pulse Duty TH Note 66 38 41 44 % - 0.2 0.3 2.5 3.0 3.5 VHL H. Out Voltage Note 67 VHH V VCO Osc. Start Voltage VOSCmin Note 68 3.0 3.5 4.0 V H. Out Start Voltage VHST Note 69 3.7 4.0 - V H. Frequency Control Range ¥ Ä fH Note 70 ¡¾ 500 ¡¾ 650 - Hz H. Freq. Control Sensitivity ¥âH Note 71 - 500 - Hz/V H. Sync. Pull-in Range ¥ Ä fHPUL Note 72 ¡¾ 450 ¡¾ 500 - Hz H. Pull-in Stop Period THSTP Note 73 - 259 ~272 - H AFC-2 Control Range TAFC2 Note 74 16 17 - ¥ìs Horizontal Position Adjustment TPAFC2 Note 75 - ¡¾ 3 - ¥ìs X-RAY Protection Detection Voltage VXDET 3.35 3.5 3.65 X-RAY Protection Hold Voltage VXHLD 3.9 4.2 4.5 X-RAY Protection Hold Current VXLD 80 100 120 ¥ìA Vertical Free Run Freq. fV - 295 - H - 224 - - 295 - - 8 - 2.2 2.4 - - 1.6 1.8 Note 76 Note 77 TVST V. Sync. Pull-in Range V. Out Pulse Width TVEND TV Note 78 Note 79 VVL V. Ramp Amplitude Control VVH Note 80 V H H V H. Sync. Separation Level Rsepa Note 81 30 35 40 % Forced V. Osc. (262.5H) fV60 Note 82 - 60 - Hz 20 M/M-97-D008 97-05-20 KA2163 21 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 22 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 23 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 24 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 25 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 26 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 27 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 28 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 29 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 30 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 31 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 32 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 33 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 34 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 35 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 36 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 37 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 38 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 39 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 40 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 KA2163 41 I2C BUS NTSC 1 CHIP IC FOR COLOR TV M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 SIGNAL FOR MEASUREMENT ¨ç Input Signal 1 Frequency fo sine wave 0.5V ¨è Input Signal 2 Frequency fo sine wave 0.5V Burst 42 M/M-97-D008 97-05-20 I2C BUS NTSC 1 CHIP IC FOR COLOR TV KA2163 TEST CIRCUIT 10k¥Ø 10¥ìF 5.1V 47¥ìF 0.01¥ìF 47k¥Ø 8.2k¥ SW30 100k¥Ø B 29 X-RAY SDA 28 30 FBP IN SCL 27 31 Sync. H.VCC 26 14 15 100PF 16 100k¥Ø B 1500PF 0.01¥ì 6 1¥ìF 2.2k¥ 5 503F30 3 2 1 32 H .OUT V SEPA FILTER 25 33 H. AFC V. RAMP 24 34 32fHVCO NFB 23 35 D. GND V. OUT 22 36 ABL B OUT 21 37 TV IN G OUT 20 38 ACL R OUT 19 39 EXT. VIDEO D. VCC 18 40 BLACK DET B IN 17 41 AV/SW OUT G IN 16 42 DC REST 43 Y IN 44 AFT 45 CHROMA IN 2.2¥ìF CSB 360¥Ø 4 1¥ìF 100¥Ø 10k¥Ø 100¥ìF 0.01¥ìF 2.2¥ìF 22k¥ 0.1¥ìF 1¥ìF 1k¥ 220k¥ 1.8k¥Ø 1.8k¥Ø 1¥ìF 75k¥Ø 3.3k¥ 0.1¥ìF 0.01¥ìF 330¥ 0.01¥ìF 47¥ìF 68¥ìF 330¥ 0.01¥ìF BPF 4.5M SW52 47pF 22¥ìH F-BLK 14 GND 13 VCXO 12 4.7k¥ 0.1¥ìF 4.7k¥ 0.1¥ìF 4.7k¥ 4.7k¥ NR18 (3.58MHz) 46 VCC 47 TV DET. OUT 48 SIF VCC APC FILTER 11 LOOP FILTER 10 PIF VCC 9 49 PIF TANK PIF IN 8 50 PIF TANK PIF IN 7 51 SIF GND RIF GND 6 52 LIMITER IN AGC FILTER 5 53 AUDIO TV IN 0.022¥ìF 100¥Ø 2200pF 0.01¥ìF 47¥ìF 3.9k¥Ø 2k¥ 47pF 9V 47¥ìF 1k¥ 15 0.1¥ìF 3.3k¥Ø Trap 4.5M 1.5¥ìF R IN 3.3V 75¥Ø 10¥ìF KA2163B 0.1¥ìF 68¥ìF 0.01¥ìF 0.47¥ìF 1000pF SIF TANK 1k¥ 4700pF 0.47¥ìF 9.1k¥ 54 DE-EMPHASIS 3 55 EXT. AUDIO SOUND OUT 2 0.01¥ìF 56 EXT. AUDIO SOUND 1 0.01¥ìF 0.47¥ìF 43 RF AGC M/M-97-D008 97-05-20 200¥ 4 75¥ 47¥ìF 0.01¥ìF 47¥ìF 220¥Ø 5.6k¥ 0.01¥ìF IF IN 13 7 1k¥Ø SAW 11 12 8 H.VCC 9 10 TC74HC123 330¥Ø 1k¥Ø 9.0 200¥ (¨öW) 47¥ 1.6k¥Ø 75¥Ø