www.make-ps.com E-mail:[email protected] 1500UFR series Single & Dual Output DC/DC Converter FEATURES • • • • • • Efficiency up to 86% 1500 VDC Isolation 4:1 Wide Input Range Remote On/Off Control UL 1950 and EN 55022 Approved >700,000 Hours MTBF INPUT CHARACTERISTICS DESCRIPTIONS The 1500UFR series is a family of 16 models DC/DC converters designed to address the application needs for data communication equipment, mobile battery driven equipment, distributed power systems, telecommunications equipment, mixed analog/ digital subsystems, process/ machine control equipment, computer peripheral systems and industrial robot systems. In addition to packing up to 15 watts of power into a 2” X 1” X 0.4” package with efficiency up to 86%, the series also has ultra-wide input ranges of 9-36VDC and 18-75 VDC, which are available in output voltage of 3.3V, 5V, 5.1V, 12V, 15V, ±5V, ±12V and ±15 VDC. OUTPUT CHARACTERISTICS Output Voltage Set Point Output Voltage Balance Line Regulation Load Regulation Ripple/Noise Over Power Protection Transient Response Deviation Transient Recovery Time Temperature Coefficient Output Short Circuit Min Typ Max Unit/Comments ±1.0 ±2.0 % Output voltage at nominal line & FL ±0.5 ±2.0 %; Equal Output Loads ±0.1 ±0.5 % Output voltage measured from min. input line to maximum ±0.5 ±1.0 % Output voltage measured from FL to 10% load 55 80 mV p-p, Nom.Line @FL, 20MHz B.W., using 1 μf bypass capacitor 120 % ±2 ±4 % deviation of Vout for a 25% load change 300 500 μS for 25% load change, to within 1% ±0.01 ±0.02 % per oC Continuous Min Typ Max Unit/Comments Start Voltage 24 VDC Input Models 48 VDC Input Models Input Fuse Requirement 24 VDC Input Models 48 VDC Input Models Under Voltage Shutdown 24 VDC Input Models 48 VDC Input Models Reverse Polarity Input Short Circuit Input Power Input Filter 8 15 8.5 17 9 18 mA; Slow blow type mA; Slow blow type 2500 1250 7 13 8 15 VDC VDC 8.5 17 1 3500 VDC VDC Amp mW Pi Filter GENERAL CHARACTERISTICS Switching Frequency Isolation Voltage Isolation Resistance Isolation Capacitance MTBF (MIL-HBK-217F) Min Typ Max Unit/Comments kHz 290 330 400 VDC, 1 minute 1500 Mohm, 500VDC 1000 1200 1500 pF, 100kHz, 1Volt Million Hours, 0.7 +25oC, Ground Benign >> B-133 www.make-ps.com E-mail:[email protected] ENVIRONMENTAL SPECIFICATIONS Operating Temp. Range Operating Temp. Range Storage Temp. Range Relative Humidity Min -40 -40 -50 PHYSICAL CHARACTERISTICS Typ Max +60 +100 +125 95 Cooling Unit/Comments o C; Ambient o C; Case o C % Humidity; noncondensing Free-Air Convection Case Size Case Material Flammability Weight Unit/Comments 1.0 X 2.0 X 0.40 inches (25.4 X 50.8 X 10.2 mm) Metal with Non-Conductive Baseplate UL94V-0 32 Grams OUTLINE DRAWING 0.40 (10.2) 0.40 (10.2) 3 4 0.10 (2.54) + Vout Common - Vout or No Pin BOTTOM 1 0.04 DIA. (1.0) 5 2 SIDE 2.00 (50.8) 6 +Vin -Vin Remote 0.40 (10.2) 0.80 (20.3) 0.60 (15.2) 0.40 (1.16) 0.24 TYP. (6.0) 0.40 (10.2) 1.00 (25.4) PIN OUT CHART Pins 1 2 3 4 5 * 6 * Single Dual + Vin + Vin - Vin - Vin + Vout + Vout No pin Common - Vout - Vout Remote On/Off (Optional) Notes: 1. Unless otherwise specified dimensions are in inches (mm). Tolerances Inches mm X.XX = ±0.02 X.X = ±0.5 X.XXX= ±0.010 X.XX = ±0.25 2. Remote On/Off is optional. Use -R suffix. All specifications are typical at nominal input, nominal load and 25° C unless otherwise specified. External, low ESR, 10 microfarad (minimum) capacitor across output is recommended for operation. >> B-134 www.make-ps.com E-mail:[email protected] HOW TO ORDER HOW TO ORDER 15 XX D XX UFR - Y Wattage Output Voltage Output Configuration, ( S=Single, D=Dual) ROHS Compliant Series Nominal Input Voltage To order the converter with Remote On/Off function, please add a suffix -R (e.g. 1505S24UFR-R) MODEL SELECTION CHART Model 15033S24UFR 1505S24UFR 1512S24UFR 1515S24UFR 1505D24UFR 1512D24UFR 1515D24UFR 15051S24UFR 15033S48UFR 1505S48UFR 1512S48UFR 1515S48UFR 1505D48UFR 1512D48UFR 1515D48UFR 15051S48UFR Nominal Input Voltage (VDC) Input Voltage Range (VDC) Output Voltage (VDC) Max. Output Current (mA) Max. Output Current (mA) No Load Input Current (mA) Full Load Input Current (mA) Reflected Ripple Current (mA) Efficiency @ FL (%) 24 24 24 24 24 24 24 24 48 48 48 48 48 48 48 48 9 - 36 9 - 36 9 - 36 9 - 36 9 - 36 9 - 36 9 - 36 9 - 36 18 - 75 18 - 75 18 - 75 18 - 75 18 - 75 18 - 75 18 - 75 18 - 75 3.3 5 12 15 ±5 ±12 ±15 5.1 3.3 5 12 15 ±5 ±12 ±15 5.1 3000 3000 1250 1000 ±1500 ±625 ±500 3000 3000 3000 1250 1000 ±1500 ±625 ±500 3000 300 300 125 100 ±150 ±62.5 ±50 300 300 300 125 100 ±150 ±62.5 ±50 300 25 25 25 25 25 25 25 25 15 15 15 15 15 15 15 15 528 762 735 726 771 735 726 787 264 381 368 363 386 368 369 393 40 40 40 40 40 40 40 40 30 30 30 30 30 30 30 30 78 82 85 86 81 85 86 81 78 82 85 86 81 85 86 81 >> B-135 www.make-ps.com E-mail:[email protected] DERATING CURVES 1500UFR - All Models Pout % 100 90 80 70 60 50 40 30 20 10 0 400LFM 200LFM 100LFM Natural Convection - 40 50 60 70 80 90 100 110 TEMPERATURE ° C >> B-136