VECTRON TFS167D

TFS167D.doc
version 1.1
VI TELEFILTER
Filter Specification
27.03.02
TFS 167D
1/5
Measurement condition
Ambient Temperature:
23
Input Power Level:
0
Terminating Impedance at fc*:
°C
dBm
input:
output:
450 Ω // -7.5 pF
470 Ω // -6.6 pF
Characteristics
Remark: Reference level for the relative attenuation arel of the TFS 167D is the minimum of the pass band attenuation amin. The minimum of
the pass band attenuation amin is defined as the insertion loss ae The centre frequency fc is the arithmetic mean value of the upper and lower
frequencies at the 3 dB filter attenuation level relative to the insertion loss ae. The temperature coefficient of frequency Tcf is valid for both the
reference frequency fc and the frequency response of the filter in the operating temperature range.
Data
typ. Value
Limit
Insertion Loss
(Reference Level)
ae = amin
4,8 dB
Nominal Frequency
fN
-
Pass Band
PB
-
fN
2,05 µs
max.
Average Group Delay within PB
Group Delay Variation within PB
Relative Attenuation
fN .....
fN ± 75
fN ±
0,2 MHz ... fN ±
0,4
fN ±
0,4 MHz ... fN ±
0,6
fN ±
0,6 MHz ... fN ±
0,8
fN - 137,0 MHz ... fN 17,0
fN 17,0 MHz ... fN 0,8
fN +
0,8 MHz ... fN + 13,0
fN + 13,0 MHz ... fN + 833,0
200
arel
kHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
Return loss in PB
max.
7,0 dB
167,0 MHz
±
75
kHz
2,3 µs
ns
max.
23
38
75
45
38
75
dB
dB
dB
dB
dB
dB
max.
min.
min.
min.
min.
min.
min.
min.
1,5
2,0
20
25
60
35
35
60
dB
dB
dB
dB
dB
dB
dB
dB
12
dB
min.
10
dB
Operating Temperature Range
400
ns p-p
-5 .....
+85
°C
Storage Temperature Range
-40.... +100
Temperature Coefficient of frequency TCf
- 0,036 ppm / K2
Out of band intermodulation
-135
dBm
°C
min.
-120
max.
15
dBm
input signals at 167,8 and 168,6 MHz at -20 dBm
input signals at 166,2 and 165,4 MHz at -20 dBm
Input power
dBm**
*) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as
reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team.
**) a power of 20 dBm can be applied shortly, for 10 years life time the cycle time should be less than 1:100
generated:
checked / approved:
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
TFS167D.doc
version 1.1
VI TELEFILTER
Filter Specification
27.03.02
TFS 167D
2/5
Construction and pin connection
(All dimensions in mm)
+0,20
P14
2,0 Max.
+0,20
19 - 0,10
1
2
3
4
5
6
7
8
9
10
date code
balanced
Input RF Return
Ground
Ground
Ground
Output
Output RF Return
Ground
Ground
Ground
Input
date code:
M
N
P
...
1,02
1
2
3
4
5
6
7
8
9
10
Input
Ground
Ground
Ground
Output
Output
Ground
Ground
Ground
Input
year + week
2000
2001
2002
2,31
1
6,50 - 0,10
TFS 167D
1
single ended
1,91
7,62
50 Ω matching circuit, single ended
L2
5
10
L1
SAW
C1
C2
1,2,3,4,6,7,8,9
200 Ω matching circuit, differential
L1
LB-IN
10
5
L2
SAW
C1
L3
C2
6
1
LB-OUT
L4
2,3,4,7,8,9
optional possible: matching circuit, input 50 Ω single ended / output 200 Ω differential
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
TFS167D.doc
version 1.1
VI TELEFILTER
Filter Specification
27.03.02
TFS 167D
3/5
Stability Characteristics
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 18 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Change of
temperature:
-55 °C to 125°C / 30 min. each / 10 cycles
DIN IEC 68 part 2 – 14 Test N
4. Resistance to
solder heat (reflow):
reflow possible: twice max.;
for temperature conditions, please refer to the attached "Air reflow temperature conditions" on page 4;
Packing
Tape & Reel:
DIN IEC 286 – 3, with exception of value for N and minimum bending radius;
tape type II, embossed carrier tape with top cover tape on the upper side;
max. pieces of filters per reel:
Reel of empty components at start:
Reel of empty components at start including leader:
Trailer
2000
min 300 mm
min 500 mm
min 300 mm
T a p e ( a ll d i m e n s io n s in m m )
P2
P1
:
:
2
12
D 1 ( m i n) :
X-X
2 8 ,4 ± 0 ,1
± 0 ,1
± 0 ,1
:
7 ,1
± 0 ,1
Bo
Ko
:
:
1 9 .6
2 ,0
± 0 ,1
± 0 ,1
t
:
0 ,3 5
:
Po
t
Ko
P2
D1
± 0 ,0 5
2 5 ,5
X
P1
Do
2
Ao
Ct
pull off direction
1 ,7 5 ± 0 ,1
:
E
:
S0
± 0 ,3
4
± 0 ,1
1 ,5
+ 0 ,5
view direction
Bo
E
32
So
:
:
Ct
:
Po
Do
W
W
Ao
X
± 0 ,1
SPEC-Gurt 0061/ 19X6,5
Q09016:02.001
Jul.10,01
W 2
Reel (all dimensions in mm):
A
:
W1
:
W2 (max) :
330
32,4 +2
38,4
N (min)
:
100
C
:
13 +0,5/-0,2
A
C
N
W 1
The minimum bending radius is 45 mm. The mounting surface of the filters faces the bottom side of the embossed carrier tape.
The marking of the filters is able to read if the view is directed on the upper side of the carrier tape in the above shown direction.
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
TFS167D.doc
version 1.1
VI TELEFILTER
Filter Specification
TFS 167D
27.03.02
4/5
Air reflow temperature conditions
1st and 2nd air reflow profile
Name:
Temperature:
Time:
pre-heating periods
150 °C – 170 °C
60 sec. – 90 sec.
main-heating periods
over 200 °C
20 sec. – 25 sec.
peak temperature
255 °C ± 5 °C
Chip-mount air reflow profile
260
240
220
200
temperature / °C
180
160
140
120
100
80
60
40
20
0
0
20
40
60
80
100
120
140
160
180
200
220
240
time / sec.
Table for temperature vs. Time during the air reflow process
Tolerance of temperatures: ± 5 °C
time / sec.
0
10
20
30
40
50
60
70
80
90
100
110
120
130
Temperature / °C
23
34
46
60
80
103
121
134
143
150
154
156
158
159
time / sec.
140
150
160
170
180
190
195
200
205
210
215
220
230
240
Temperature / °C
160
161
164
170
180
205
230
255
230
205
180
165
140
120
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
TFS167D.doc
VI TELEFILTER
version 1.1
Filter Specification
27.03.02
TFS 167D
5/5
History
Version
Reason of Changes
Name
Date
1.0
- generation of specification according to customer requirements
Pfeiffer
14.11.2001
1.1
- terminating impedances added
- typical values added
Pfeiffer
27.03.2002
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.