H HiTRON UNIVERSAL INPUT HARMONIC CORRECTION(PFC) AC-DC INTELLIGENT BATTERY CHARGER 2000 WATTS SINGLE OUTPUT HIBA2000 SERIES FEATURES: MICROPROCESSOR CONTROLLED POWER MANAGEMENT MULTI-RACK SHELF PARALLELING SUPPORTED 2 STAGE CHARGING WIDE OPERATING TEMPERATURE REVERSE POLARITY/UNDER VOLTAGE/ OVER VOLTAGE/OVER TEMP. PROTECTION LED LOADING INDICATOR FOR POWER & CHARGER STATUS CANBus/RS485/RS422 INTERFACE SPECIFICATION INPUT SPECIFICATION OUTPUT SPECIFICATION Input Voltage: 90-264Vac. Power Factor: Meet Harmonic Correction IEC 61000-3-2. Power Factor typ. 0.98. Input Connector: 3 prong LT-262B or YP16L 20A/250V. Input Frequency: 47-63Hz. Inrush Current: 15A(rms) at 230Vac; 40A (peak) at 230Vac. Input Current: Typ. 14.8A at 115Vac / 9.6A at 230Vac. Under Voltage Protection: Available. Dielectric Withstand: Meet IEC 60950-1. EMI: Meet CISPR EN55022A/CISPR EN55014-1. Hold-up Time: Typ. 25ms at 115Vac/ 20mS at 230Vac. Remote ON/OFF: Available. Over Temp. Protection (OTP): By NTC, thermostat & Temp. sensor Leakage Current: Typ. 0.82mA at 230Vac. No-Load Power: 15.1Watt at 115Vac/ 13.3Watt at 230Vac. Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Output Power: 2000W. Output Connector: PB-50(50A/600V). Line Regulation: Typ. ±0.5%. Noise & Ripple: Typ. 1% peak-peak. Cut-off Current: Software programming. Over Voltage Protection (OVP): Built-in. Current Sharing: Available. Output Reverse polarity Protection: Available. Over Current Protection (OCP): Software programming. Multi-rack shelf paralleled: Available. Charging Indicator: Green means Battery Full. Red means Fail. Green/Red means Charring. Overload Protection (OLP): Fully protected against output overload or short circuit. GENERAL SPECIFICATION Operating Temperature: -20 °C to +60 °C de-rate linearly Efficiency: 88.5% at 230Vac. from 100% power at +50 °C Switching Frequency: 55KHz. to 60% power at +60 °C. Circuit Topology: Full-bridge circuit. (Refer to de-rating chart). Safety Standard: Meet IEC 60950-1/EN60335-1& EN60335-2-29 Storage Temperature: -40°C to +85 °C. Class I. Cooling: Built-in dual internal DC ball bearing fans Battery Type: Lead-acid/ Ultra-capacitor/Li-Ion/LiFePO4. with smart fan speed control. Charge Mode: CV+CC. Power Density: 7.2 Watts/ cubic inch. CANBus/RS485/RS422 Interface. NOTE: (1)All measurement are at nominal input, full load and +25°C unless otherwise specifications. (2)Due to requests in market and advances in technology, specifications subject to change without notification. (3)Derating is needed under low input voltage. Please refer to the derating chart. Hitron Electronics Corporation. B4-11, P.O. Box 26-110 Kaohsiung Export Processing Zone Kaohsiung 806 Taiwan TEL: 886-7-8210410/FAX: 886-7-8419917, 886-7-8210511/E-mail: [email protected]/[email protected] /Web-site: www.hitron-e.com 1 Edited on April 17 2014 OUTPUT VOLTAGE / CURRENT RATINGS CHART SINGLE OUTPUT MODEL NO. HIBA2000-S540370 HIBA2000-S584343 HIBA2000-S828242 VO1 ★⊙≡ Min. 0A 0A 0A Typ. 37.0A 34.3A 24.2A Volt. 54.0V 58.4V 82.8V Max. 37.0A 34.3A 24.2A Symbol: "★" OVP built-in. "≡" Load Sharing. "⊙" Installed with Or-ing diode. MECHANICAL DIMENSIONS: MM [INCHES] WEIGHT: 4.2kgs (9.26lb) DERATING CHART (When I/P ≧ 180VAC) CHARGING CURVE INPUT & OUTPUT CONNECTORS PIN ASSIGNMENT ASSIGNMENT PIN NO. AC-LINE P1-L AC-NEUTRAL P1-N AC-GROUND P1-G VO1 P2-1 DC COM P2-2 Hitron Electronics Corporation. B4-11, P.O. Box 26-110 Kaohsiung Export Processing Zone Kaohsiung 806 Taiwan TEL: 886-7-8210410/FAX: 886-7-8419917, 886-7-8210511/E-mail: [email protected]/[email protected] /Web-site: www.hitron-e.com 2 Edited on April 17 2014