tfs125B.doc Version 1.0 VI TELEFILTER Filter Specification 06.03.01 TFS 125 B 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedances: 23 0 50 °C dBm Ω Characteristics Remark: Reference level for the relative attenuation arel of the TFS 125 B is the minimum attenuation in the pass band. The minimum attenuation in the pass band is defined as the insertion loss ae. The nominal frequency fN is fixed at 125 MHz without tolerance or limit. The values of relative attenuation arel are guaranteed in the whole operating temperature range. The frequency shift of the filter in the operating temperature range is included in the production tolerance scheme. Data typ. value tolerance / limit ______________________________________________________________________________________________________ Insertion loss 1,5...... 3,5 dB ae (Reference level) ______________________________________________________________________________________________________ Nominal frequency 125,0 MHz fN ______________________________________________________________________________________________________ 1 dB bandwidth min. 300,0 kHz BW ______________________________________________________________________________________________________ Relative attenuation arel fN ..... fN ± 150 KHz max. 1,0 dB MHz min. 12,0 dB fN –124,0 MHz ... fN - 28 MHz min. 5,0 dB fN – 28,0 MHz ... fN - 14 min. 30,0 dB fN + 13,5 MHz ... fN +14,5 MHz min. 15,0 dB fN + 14,5 MHz ... fN +28,0 MHz MHz ... fN +325,0 MHz min. 38,0 dB fN + 28 ______________________________________________________________________________________________________ VSWR within ± 150 KHz max 2,0 : 1 ______________________________________________________________________________________________________ Absolute group delay GD max. 300,0 ns Group delay ripple GDD *) within ± 150 KHz max. 30,0 ns ______________________________________________________________________________________________________ Intermodulation **) IP3 54 dB min. 45,0 dB ______________________________________________________________________________________________________ Input power level max. 10,0 dBm ______________________________________________________________________________________________________ Temperature coefficient of frequency - 71,6 ppm/K TCf ***) Operating temperature range - 10 °C ... + 85 °C ______________________________________________________________________________________________________ *) measured with smoothing; smoothing aperture ≤ 50 kHz **) modulation signals: fN and fN + 14 MHz, each of 10 dBm; measured signal: ***) ∆f(Hz) = TCf(ppm/K) x (∆T) x fTo(MHz) fN - 14 MHz generated: checked / approved: VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. tfs125B.doc Version 1.0 VI TELEFILTER Filter Specification 06.03.01 TFS 125 B 2/5 Construction and pin connection (All dimensions in mm) TFS 125 B N09 Date code 1 2 3 4 5 6 7 8 9 10 Ground Ground Ground Ground Output Ground Ground Ground Ground Input Date code: Year+week L 1999 M 2000 N 2001 ... Recommended land dimensions VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. tfs125B.doc Version 1.0 VI TELEFILTER 06.03.01 Filter Specification TFS 125 B 3/5 Stability characteristics After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 18 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Damp heat: (cycle) 25 °C to 55°C / 95% r.H. / 10 cycles DIN IEC 68 - 2 – 30 Db 4. Resistance to solder heat (reflow): max. 2 times reflow process; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; Packing Tape & Reel: IEC 286 - 3, with exception of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: Reel of empty components at start: Reel of empty components at start including leader: Trailer Tape (all dimensions in mm) W Po : : 16 4 Do E : : 1,5 + 0,1 1,75 ± 0,1 EMBOSSED CARRIER TAPE ± 0,3 ± 0,1 F : G (min) : 7,5 ± 0,1 0,60 P2 : P1 : D1(min) : 2 ± 0,1 8 ± 0,1 1,5 Ao Bo : : 5,30 ± 0,2 9,70 ± 0,2 CT : 13,5 3000 min 300 mm min 500 mm min 300 mm Do Po P2 E Ao F D1 W Bo CT G P1 ± 0,1 COVER TAPE W 2 Reel (all dimensions in mm): A : W1 W2 (max) : : N (min) : 330 16,40 +2,0 22,4 50 C C : 13,0 A ± 0,5/-0.2 N W 1 The minimum bending radius is 45 mm. The mounting surface of the filters faces the bottom side of the embossed carrier tape. The marking of the filters is able to read if the view is directed on the upper side of the carrier tape with the sprocket holes on the right side of the tape. VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. tfs125B.doc Version 1.0 VI TELEFILTER 06.03.01 Filter Specification TFS 125 B 4/5 Air reflow temperature conditions 1st and 2nd air reflow profile Name: Temperature: Time: pre-heating periods 150 °C - 170 °C 60 sec. - 90 sec. main-heating periods over 200 °C 20 sec. - 25 sec. peak temperature 255 °C ± 5 °C Chip-mount air reflow profile 260 240 220 200 temperature / °C 180 160 140 120 100 80 60 40 20 0 0 20 40 60 80 100 120 140 160 180 200 220 240 time / sec. Table for temperature vs. time during the air reflow process Tolerance of temperatures: ± 5 °C time / sec. 0 10 20 30 40 50 60 70 80 90 100 110 120 130 temperature / °C 23 34 46 60 80 103 121 134 143 150 154 156 158 159 VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] time / sec. 140 150 160 170 180 190 195 200 205 210 215 220 230 240 temperature / °C 160 161 164 170 180 205 230 255 230 205 180 165 140 120 Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. tfs125B.doc Version 1.0 VI TELEFILTER Filter Specification 06.03.01 TFS 125 B 5/5 History Version Reason of Changes Name Date 1.0 - generated specification according to customer requirement specification Steiner 06.03.2001 VI TELEFILTER Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] Vectron International, Inc. 267 Lowell Road Hudson, NH 03051 / USA Tel: (603) 598-0070 Fax: (603) 598-0075 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.