VECTRON TFS70L14

Tfs70L14.doc
version 1.1
VI TELEFILTER
Filter Specification
11.09.2001
TFS 70L14
1/5
1. Measurement condition :
25 °C
0 dBm
for input:
for output:
Ambient temperature TA:
Input power level:
Terminating impedances in fc * ):
100
131
- 15,914 pF.
- 15,275 pF.
2. Characteristics
Remark:
Reference level for the relative attenuation a rel of the TFS 70L14 is the minimum of the pass band attenuation amin. The minimum of the pass
band attenuation amin is defined as the insertion loss a e. The reference frequence f c is the arithmetic mean value of the upper and lower
frequencies at the 3 dB filter attenuation level relative to the insertion loss ae. The temperature coefficient of frequency Tcf is valid both for the
reference frequency f c and the frequency response of the filter in the operating temperature range. The frequency shift of the filter in the
operating temperature range is not included in the production tolerance scheme.
Data
typ. value
Insertion loss (Reference level)
Centre frequency
ae
11 dB
fc at ambient temperature (fCTA)
70
MHz
Pass band ( PB ) :
tolerance / limit
max.
12,5 dB
70,0 ± 0,10
MHz
fC - 6,5 MHz ... fC + 6,5 MHz
Amplitude ripple in PB (p-p) :
0,4
dB
max.
1
dB
MHz
MHz
min.
min.
13,0 MHz
14,0 MHz
dB
dB
max.
max.
min.
min.
1
3
40
40
µs
ns
degree
max.
max.
max.
1,5 µs
90
ns
11
degree
Bandwidth at ambient temperature TA:
1 dB - band width
3 dB - band width
Relative attenuation
fc ± 6,5
fc - 20
fc + 10,35
fc ...
MHz ...
MHz ...
MHz ...
13,35
14,50
arel
fc
fc
fc
fc
±
6,5
±
7,0
9,65
+ 20
MHz
MHz
MHz
MHz
Group delay ( mean value in PB ):
Group delay ripple (p-p) in 90% of 3dB Bandwidth :
Deviation from linear phase (p-p) in 90% of 3dB Bandwidth :
Triple transit attenuation compared to main signal
Crosstalk attenuation compared to main signal
Temperature coefficient of frequency ( Tcf )
Frequency deviation of f c over temperature
43...45
43...45
1,1
65
6,5
-
dB
dB
dB
dB
dB
dB
- 87
ppm/K
-94
fc(Hz) = Tcf(ppm/K) x (T - T A) x fCTA (MHz)
ppm/K
- 20 °C ... + 70 °C
- 40 °C ... + 85 °C
Operating temperature range ( O.T.R. )
Storage temperature range
*) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as
reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team.
Generated:
Dunzow W.
Checked/Approved:
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Tfs70L14.doc
version 1.1
VI TELEFILTER
Filter Specification
TFS 70L14
11.09.2001
2/5
3. Package, pin grid 2,54 mm :
13,6 Max.
TFS
70 L14
N34
6,8 Max.
Datecode:
L
M
N
Year+week
1999
2000
2001
.......
.......
1
2,0 Max.
2,54 ± 0,15
1,2
1
2
3
4
12
5
2,54 ± 0,15
11
6
10
4. 50
9
0,8
8
Pin 11 - Input.
Pin 12 - Input RF Return.
Pin 5 - Output.
Pin 6 - Output RF Return.
Pin 1-4, 7-10 PackageGround.
7
0,1
- Matching network ( about matching element values see Application Note ):
1
Scheme 1
2
3
4
L2
12
5
11
6
C1
50
L1
50
C2
10
9
8
7
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Tfs70L14.doc
version 1.1
VI TELEFILTER
Filter Specification
11.09.2001
TFS 70L14
3/5
5. Stability characteristics :
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 18 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Change of
temperature
-55 °C to 125°C / 30 min. each / 10 cycles
DIN IEC 68 part 2 – 14 Test N
4. Resistance to
solder heat (reflow):max. 2 times reflow process;
for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4;
6. Packing :
Tape & Reel:
DIN IEC 286 - 3, with exception of value for N and minimum bending radius;
tape type II, embossed carrier tape with top cover tape on the upper side;
max. pieces of filters per reel:
reel of empty components at start:
reel of empty components at start including leader:
Trailer
1700
min 300 mm
min 500 mm
min 300 mm
EMBOSSED CARRIER TAPE
Tape (all dimensions in mm)
Do
W
Po
Do
E
F
G (min)
P2
P1
D1(min)
Ao
Bo
CT
:
:
:
:
:
:
:
:
:
:
:
:
24± 0,3
4
± 0,1
1,5
+ 0,1
1,75 ± 0,1
11,5 ± 0,1
0,6
2
± 0,1
12
± 0,1
1,5
7,1
± 0,2
13,9 ± 0,2
21,5 ± 0,1
Po
P
2
E
A
o
F
D
CT
1
W
Bo
G
P1
COVER TAPE
W2
Reel (all dimensions in mm):
A
W1
W2(max)
N(min)
C
:
:
:
:
:
330
24,4 + 2
30,4
60
13 +0,5/-0,2
A
C
N
W1
The minimum bending radius is 45 mm. The mounting surface of the filters faces the bottom side of the embossed carrier tape.
The marking of the filters is able to read if the view is directed on the upper side of the carrier tape with the sprocket holes on the
right side of the tape.
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Tfs70L14.doc
version 1.1
VI TELEFILTER
Filter Specification
11.09.2001
TFS 70L14
4/5
7. Air reflow temperature conditions :
1st and 2nd air reflow profile
Name:
Temperature:
Time:
pre-heating periods
150 °C - 170 °C
60 sec. - 90 sec.
main-heating periods
over 200 °C
20 sec. - 25 sec.
peak temperature
255 °C ± 5 °C
Chip-mount air reflow profile
260
240
220
200
temperature / °C
180
160
140
120
100
80
60
40
20
0
0
20
40
60
80
100
120
140
160
180
200
220
240
time / sec.
Table for temperature vs. time during the air reflow process
Tolerance of temperatures: ± 5 °C
time / sec.
0
10
20
30
40
50
60
70
80
90
100
110
120
130
temperature / °C
23
34
46
60
80
103
121
134
143
150
154
156
158
159
time / sec.
140
150
160
170
180
190
195
200
205
210
215
220
230
240
temperature / °C
160
161
164
170
180
205
230
255
230
205
180
165
140
120
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Tfs70L14.doc
VI TELEFILTER
version 1.1
Filter Specification
11.09.2001
TFS 70L14
5/5
History
Version
Reason of Changes
Name
Date
1.0
Generate Preliminary specification.
Dunzow W.
28.08.2001
1.1
Generate Filter specification.
Dunzow W.
11.09.2001
VI TELEFILTER
Vectron International, Inc.
Potsdamer Straße 18
267 Lowell Road
D 14 513 TELTOW / Germany
Hudson, NH 03051 / USA
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
Tel: (603) 598-0070 Fax: (603) 598-0075
E-Mail: [email protected]
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.