Filename: tfs 380n.doc Version 1.1 VI TELEFILTER 10.10.2005 Filter specification TFS 380N 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedance: * Input: Output: 23 0 °C dBm 499 Ω || -6,3 pF 480 Ω || -6,2 pF Characteristics Remark: The nominal frequency fN is fixed at 380 MHz. The insertion loss ae is defined as loss value determined at fN. Reference level for the relative attenuation arel of the TFS 380N is the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 30 dB filter attenuation level relative to the insertion loss ae. All specified data are met within the operating temperature range. Data typ. value Insertion loss at fN (reference level) ae Nominal frequency fN Centre frequency at ambient temperature fC Passband PB max. 11 380,0 MHz fN ± dB 380,0 MHz ± 0,4 MHz 2,0 MHz 0,8 dB max. 1,5 dB 0,5 1 dB dB max. max. 1 3 dB dB arel fC fC ± 3,0 MHz … fC MHz … fC ± ± fC ± 7,5 MHz … fC ± Group delay ripple in fN ± 2,5 dB - Pass band ripple Relative attenuation 8,5 tolerance / limit 3,0 3,75 50,0 MHz MHz MHz MHz Operating temperature range OTR Storage temperature range Temperature coefficient of frequency 34 dB min. 30 dB 46 ns max. 75 ns - - 40 °C … +85 °C TCf ** -18 - 40 °C ... + 85 °C ppm/K *) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team. **) ∆fc(Hz) = Tcf(ppm/K) x (T - TA) x fCAT (MHz) Generated: Checked / Approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 380n.doc Version 1.1 VI TELEFILTER 10.10.2005 Filter specification TFS 380N 2/5 0 0.91 -1 0.85 -10 -2 0.79 -15 -3 0.73 -20 -4 0.67 -5 0.61 -6 0.55 -35 -7 0.49 -40 -8 0.43 -45 -9 0.37 -25 -30 -50 330 340 350 360 370 380 390 frequency in MHz 400 410 420 -10 375 430 376 377 378 379 380 381 frequency in MHz 382 383 384 delay in µs 0 -5 magnitude in dB magnitude in dB Filter characteristic 0.31 385 Construction and pin connection (All dimensions in mm) S 380N ● T42 3 Date code 2 Max. 1 1 5,2 Max. 2,54 ±0,2 7,2 Max. 2,54 ±0,2 1 1 2 3 4 5 6 7 8 9 10 11 12 Ground Ground Output RF Return Output Ground Ground Ground Ground Input RF Return Input Ground Ground Date code: T U V ... Year + week 2005 2006 2007 0,80 50 Ω Test circuit 10 L1 9 4 SAW L2 L3 3 L4 1, 2, 5, 6, 7, 8, 11, 12 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 380n.doc Version 1.1 VI TELEFILTER 10.10.2005 Filter specification TFS 380N 3/5 Stability characteristics After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 1 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: twice max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; Packing Tape & Reel: IEC 286 – 3, with exeption of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters peer reel: reel of empty components at start: reel of empty components at start including leader: trailer: 3000 min. 300 mm min. 500 mm min. 300 mm Pull Off Direction Tape (all dimensions in mm) W : 16,00 ± 0,3 Po : 4,00 ± 0,1 Do : 1,50 +0,1/-0 E : 1,75 ± 0,1 F : 7,50 ± 0,1 G(min) : 0,60 P2 : 2,00 ± 0,1 P1 : 8,00 ± 0,1 D1(min) : 1,50 Ao : 5,50 ± 0,1 Bo : 7,50 ± 0,1 Ct : 13,5 ± 0,1 t P1 Date Code Po P2 W G Ct Bo F G E Do Ko Typ PIN Marker D1 Ao W 2 Reel (all dimensions in mm) A : 330 W1 : 16,4 +2/-0 W2(max) : 22,4 N(min) : 50 C : 13,0 +0,5/-0,2 A C N W 1 The minimum bending radius is 45 mm. Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 380n.doc Version 1.1 VI TELEFILTER 10.10.2005 Filter specification TFS 380N 4/5 Air reflow temperature conditions Conditions Average ramp-up rate (30°C to 217°C) > 100°C > 150°C > 217°C Peak temperature Time within 5°C of actual peak temperature Cool-down rate (Peak to 50°C) Time from 30°C to Peak temperature Exposure less than 3°C/second between 300 and 600 seconds between 240 and 500 seconds between 30 and 150 seconds max. 260°C between 10 and 30 seconds less than 6°C/second no greater than 300 seconds Chip-mount air reflow profile Temperature / °C max. 260°C 217°C max. 300 s 10 ... 30 s Time / s 30 ... 150 s Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 380n.doc VI TELEFILTER Version 1.1 Filter specification 10.10.2005 TFS 380N 5/5 History Version Reason of Changes Name Date 1.0 Generation of development specification Strehl 22.09.2005 1.1 terminating impedance, typical values and filter characteristic added Pfeiffer 10.10.2005 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.