CRYDOM PB24HQ

PB24HQ
MOUNTING BOARD
• Plug-compatible logic connections
• Screw terminal barrier block for load connections
• 5 amp field-replaceable fuses
• Input and output modules accepted interchangeably
• Operate with 5, 15 or 24 volt logic supplies
• Captive-screw retaining system for Quad-Pack
(LITTLEFUSE #251005 or equivalent)
modules
• All even-numbered logic connections are
logic ground
MECHANICAL SPECIFICATIONS
8.0 (203,2)
DIMENSIONS: INCHES (MILLIMETERS)
TOLERANCE: ±0.20 (±0.50)
7.5 (190,5)
0.25 (6,4)
0.25 (6,4)
1
2
SWAGED STANDOFF
THRU HOLE
0.15 (3,8) DIA.
x 0.75 (19,1) LONG (4)
C
C
3
4
5
6
C
C
7
8
9
10
C
C
11 13
12 14
C
C
15 17
16 18
C
C
19 21
20 22
C
C
23
24
POWER BARRIER
STRIPS
(SEE NOTE 2,3
F8
F7
F10
F9
F12
F11
SPARE
F6
F5
SPARE 5A
LINE FUSE
5.5 (139,7)
6.0 (152,4)
F4
F3
5A FUSE
F13
F2
F1
REPLACEABLE 5A
LINE FUSE (12)
(SEE NOTE 5)
GORDOS QUAD-PACK
DIGITAL 1/0 MODULES
SOLD SEPERATELY
F1A
0-3
4-7
D1
8 - 11
20-23
16-19
12-15
R1J1
D2
TB2
P1
CROUZET
57–464
PB–24HQ
PWR
ON
+5V GND
REPLACEABLE
1A FUSE LOGIC
SUPPLY FUSE
(SEE NOTE 4)
3.9 (99,1)
4) LITTLE FUSE 251001 OR EQUIVALENT.
5) LITTLE FUSE 251005 OR EQUIVALENT.
NOTES: 1) CONNECTOR IS CIRCUIT ASSEMBLY CA-50H-2B-SR OR EQUIVALENT.
2) 6-32 SCREW TERMINAL BARRIER STRIPS ACCEPT WIRE SIZES FROM 24 TO 12 AWG.
3) OPTIONAL JUMPERS AVAILABLE TO INTERCONNECT BARRIER STRIP COMMONS.
ORDER 2 EACH JUMPERS "JQ2" AND 4 EACH JUMPERS "JQ4".
JQ4 REQUIRES CUSTOMER MODIFACATIONS TO USE WITH PB24HQ.
1
C
3
5
C
7
9
SIGNAL INPUT / OUTPUT
50 CONDUCTOR MALE PIN CONNECTOR
(SEE NOTE 1 )
4–40 SCREW TERMINAL LOGIC
SUPPLY BARRIER STRIP
C
11
13
C
17
15
C
19
21
23
C
LOWER BARRIER STRIP
LOGIC SUPPLY
BARRIER STRIP
+5V
GND
2
C
4
6
C
8
10
C
12
14
C
16
18
20
C
22
24
C
UPPER BARRIER STRIP
D1
1 AMP
LOGIC
SUPPLY
FUSE
J1
49
5 AMP LINE FUSES (12)
PWR
ON
1
8
1
8
1
8
1
8
1
8
1
8
2
9
2
9
2
9
2
9
2
9
2
9
3
10
3
10
3
10
3
10
3
10
3
10
4
11
4
11
4
11
4
11
4
11
4
11
5
12
5
12
5
12
5
12
5
12
5
12
6
13
6
13
6
13
6
13
6
13
6
13
7
14
7
14
7
14
7
14
7
14
7
14
I/O MODULE
PIN SOCKETS
EVEN
PINS
SIGNAL
INPUT/OUTPUT
50 CONDUCTOR
MALE PIN
CONNECTOR
TO RIBBON CABLE
2-50
47
45
43
41
39
37
35
33
31
29
27
25
23
21
19
17
15
13
11
9
7
5
3
1
Rev. 070808
DANGER / PELIGRO / DANGER /GEFAHR / PERICOLO / PERIGO
HAZARD OF
ELECTRIC
SHOCK,
EXPLOSION,
OR ARC FLASH.
• Disconnect all
power before
installing or
working with
this equipment.
• Verify all
connections
and replace all
covers before
turning on
power.
Failure to follow
these
instructions will
result in death
or serious injury.
RIESGO DE
DESCARGA
ELECTRICA O
EXPLOSION.
• Desconectar
todos los
suministros de
energia a este
equipo antes
de trabajar
con este equipo.
• Verificar todas
las conexiones
y colocar todas
las tapas antes
de energizer
el equipo.
El
incumplimiento
de estas
instrucciones
puede provocar
la muerte o
lesiones serias.
RISQUE DE
DESCHARGE
ELECTRIQUE
OU EXPLOSION
• Eteindre
toutes les
sources
d'énergie de
cet appareil
avant de
travailler
dessus de cet
appareil
• Vérifier tous
connections, et
remettre tous
couverts en
olace avant de
mettre sous
De non-suivi de
ces instructions
provoquera la
mort ou des
lésions sérieuses
sérieuses.
GEFAHR EINES
ELEKTRISCHE
N SCHLAGES
ODER EINER
EXPLOSION.
• Stellen Sie
jeglichen
Strom ab, der
dieses Gerät
versorgt, bevor
Sie an dem
Gerät Arbeiten
durchführen
• Vor dem
Drehen auf
Energie alle
Anschlüsse
überprüfen
und alle
Abdeckungen
ersetzen.
Unterlassung
dieser
Anweisungen
können zum
Tode oder zu
schweren
Verletzungen
führen.
RISCHIO DI
SCOSSA
ELETTRICA O
DELL’ESPLOSI
ONE.
• Spenga tutta
l'alimentazion
e che fornisce
questa
apparecchiatu
ra prima del
lavorare a questa
apparecchiatu ra
• Verificare tutti
i collegamenti
e sostituire
tutte le coperture
prima della
rotazione
sull'alimentazi one
L'omissione di
seguire queste
istruz ioni
provocherà la
morte o di
lesioni serie
RISCO DE
DESCARGA
ELÉTTRICA OU
EXPLOSÃO
• Desconectar
o equipamento
de toda á
energia antes
de instalar ou
trabalhar com
este equipamen
to
• Verificar todas
as conexões e
recolocar todas
as tampas
antes de religar
o equipamento
O não cumprimento
destas instruções
pode levar á morte
ou lesões sérias.
ANNEX - ENVIROMENTAL INFORMATION