Frontier Electronics Corp. 667 E. COCHRAN STREET, SIMI VALLEY, CA 93065 TEL: (805) 522-9998 FAX: (805) 522-9989 E-mail: [email protected] Web: http://www.frontierusa.com 20A ULTRA FAST RECOVERY RECTIFIER UF200-005 THRU UF200-06 FEATURES z DUAL RECTIFIER CONSTRUCTION, POSITIVE CENTER TAP 3.4±0.1 z PLASTIC PACKAGE HAS UNDERWRITERS LABORATORY FLAMMABILITY CLASSIFICATION 94V-0 z GLASS PASSIVATED CHIP JUNCTIONS z SUPER FAST RECOVERY TIMES, HIGH VOLTAGE z LOW FORWARD VOLTAGE, HIGH CURRENT CAPABILITY z LOW THERMAL RESISTANCE z LOW POWER LOSS, HIGH EFFICIENCY z HIGH TEMPERATURE SOLDERING GUARANTEED: 260°C / 0.17” (4.3mm) FROM CASE FOR 10 SECONDS A B M C N D F E 1 2 3 G H o L P MECHANICAL DATA z CASE: JEDEC TO-3P MOLDED PLASTIC , DIMENSIONS IN INCHES AND (MILLIMETERS) z TERMINALS: PLATED LEAD SOLDERABLE PER MIL-STD202, METHOD 208 z POLARITY: AS MARKED z MOUNTING POSITION: ANY z WEIGHT: 6.4 GRAMS A B C D E F G H I J K L M N O p MILLIMETERS MIN MAX 16.2 1.7 2.7 5.0 6.0 22.0 14.8 15.2 11.7 12.7 4.5 2.5 3.5 1.1 1.4 5.25 5.65 19.0 4.7 5.3 2.8 3.2 2.4 2.8 0.45 0.85 K PIN 1 PIN 2 PIN 3 CASE MAXIMUM RATINGS AND ELECTRICAL CHARACTERISTICS RATINGS AT 25°C AMBIENT TEMPERATURE UNLESS OTHERWISE SPECIFIED SINGLE PHASE, HALF WAVE, 60 HZ, RESISTIVE OR INDUCTIVE LOAD. FOR CAPACITIVE LOAD, DERATE CURRENT BY 20% UF200 UF200 UF200 UF200 UF200 UF200 UF200 UF200 UNITS RATINGS SYMBOL -005 -01 -015 -02 -03 -04 -05 -06 MAXIMUM RECURRENT PEAK REVERSE VOLTAGE VRRM 50 100 150 200 300 400 500 600 V MAXIMUM RMS VOLTAGE VRMS 35 70 105 140 210 280 350 420 V MAXIMUM DC BLOCKING VOLTAGE VDC 50 100 150 200 300 400 500 600 V MAXIMUM AVERAGE FORWARD RECTIFIED CURRENT IO 20.0 A SEE FIG.1 PEAK FORWARD SURGE CURRENT, 8.3ms SINGLE HALF IFSM 250 A SINE-WAVE SUPERIMPOSED ON RATED LOAD TYPICAL JUNCTION CAPACITANCE (NOTE 1) CJ 65 PF TYPICAL THERMAL RESISTANCE (NOTE 2) 2.0 ℃/W R θjC STORAGE TEMPERATURE RANGE TSTG - 55 TO + 150 ℃ OPERATING TEMPERATURE RANGE TOP - 55 TO + 150 ℃ ELECTRICAL CHARACTERISTICS (AT TA =25°C UNLESS OTHERWISE NOTED) UF200 UF200 UF200 UF200 UF200 UF200 UF200 UF200 UNITS CHARACTERISTICS SYMBOL -005 -01 -015 -02 -03 -04 -05 -06 MAXIMUM FORWARD VOLTAGE AT 10A PER LEG VF 1.0 1.3 1.5 V MAXIMUM DC REVERSE CURRENT AT TA=25°C IR 10 μA MAXIMUM DC REVERSE CURRENT AT TA=100°C IR 100 μA MAXIMUM REVERSE RECOVERY TIME (NOTE 3) TRR 35 50 nS NOTES: 1. MEASURED AT 1 MHZ AND APPLIED REVERSE VOLTAGE 0F 4.0 VOLTS 2. THERMAL RESISTANCE JUNCTION TO CASE PER LEG MOUNTED ON HEAT SINK 3. REVERSE RECOVERY TEST CONDITIONS: IF=0.5A, IR=1.0A, IRR=0.25A UF200-005 THRU UF200-06 Page: 1 RATINGS AND CHARACTERISTIC CURVE UF200-005 THRU UF200-06 FIG. 1 -TEST CIRCUIT DIAGRAM AND REVERSE RECOVERY TIME CHARACTERISTIC Trr 10Ω NO INDUCTIVE 50Ω NO INDUCTIVE +0.5A (-) D.U.T. 0 PULSE GENERATOR ( NOTE 2 ) (+) 25 Vdc (approx) 1Ω NON INDUCTIVE (-) OSCILLOSCOPE ( NOTE 1 ) -0.25A (+) -1.0A 1cm SET TIME BASE FOR 10/20 ns/cm NOTE: 1. RISE TIME=7ns MAX. INPUT IMPEDANCE=1 MOhms 22PF 2. RISE TIME =10 ns MAX. SOURCE IMPEDANCE=50 OHMS FIG. 3 -TYPICAL INSTANTANEOUS FORWARD CHARACTERISTICS FIG. 2 -TYPICAL FORWARD CURRENT DERATING CURVE CASE TEMPERATURE ( C) 20 AVERAGE FORWARD CURRENT (A) 16 12 8 4 0 Single Phase Half Wave 60Hz Resistive or Inductive Load 25 50 75 100 125 150 175 INSTANTANEOUS FORWARD CURRENT (A) 100 o 10 UF200-005~02 1.0 .1 UF200-03~06 .01 0 .2 .4 .6 .8 1.0 1.2 1.4 1.6 1.8 INSTANTANEOUS FORWARD VOLTAGE (V) FIG. 5 -TYPICAL JUNCTION CAPACITANCE 1000 200 JUNCTION CAPACITANCE (pF) INSTANTANEOUS REVERSE CURRENT (uA) FIG. 4 -TYPICAL REVERSE CHARACTERISTICS 100 10 o TJ=125 C TJ=80oC 1 TJ=25oC 0.1 20 40 60 80 100 120 140 PERCENT OF RATED PEAK REVERSE VOLTAGE (%) 100 40 20 TJ=25oC 10 6 4 2 1 .1 .2 .4 1.0 2 4 10 20 40 100 REVERSE VOLTAGE (V) UF200-005 THRU UF200-06 Page: 2