TOTAL POWER INT'L UNIVERSAL AC INPUT HARMONIC CORRECTION AC-DC HOT-SWAP CompactPCI QUAD OUTPUT 500 WATTS ACTIVE CURRENT SHARING SWITCHING POWER SUPPLIES TPAC500P SERIES FEATURES: 500W 6U X 8HP EUROCARD PACKAGE MEET IEC1000-3-2 HARMONIC CORRECTION INTERNAL OR-ING DIODES FOR N+1 REDUNDANCY HOT-SWAPPABLE THIRD-WIRE CURRENT SHARING EMI MEET EN 55022 / CLASS A CE MARKING COMPLIANCE FULLY COMPLIANT WITH PICMG SPECIFICATION INPUT SPECIFICATION OUTPUT SPECIFICATION Input Voltage: Typ. 90-264Vac. Input On/Off switch: Option. Power Factor Correction: Meet Harmonic Correction IEC1000-3-2.Power Factor typ. 0.99. Input Connector: Positronic 47-pin PCIH47M400A1. Input Frequency: 47-63Hz. Inrush Current: ≤ 30.6A(rms) @ 230Vac. Input Current: 5.1A@115Vac/2.6A @230Vac. Dielectric Withstand: Meet IEC950 regulation. Transient Protection: MOV withstands transient as specified by EN61000-4-4 level 3. EMI: Meet EN55022 Class A. Hold-up Time: 22.4mS @ 115Vac,34mS @ 230Vac. Remote ON/OFF: Available at [INH#] & [EN#] pins. Power Fail Signal: Available at [FAL#] pin. Status LED: <Green> means valid input voltage. <Amber> means a critical fault. Thermal Protection (OTP): Installed NTC and thermostat for thermal sensor at [DEG#] pin. Power OK: Installed at all outputs. Leakage Current: Typ. 0.7mA @ 230Vac. Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Output Power: Typ. 500W continuous. Output Connector: Positronic 47-pin PCIH47M400A1. Line Regulation: Typ. 0.1%. Load Regulation: VO1 & VO2 typ. ±0.5%. VO3 typ. ±1.0%, VO4 typ. ±3.0%. Noise & Ripple: Typ. 1% peak-peak or 50mV,which is greater. OVP: Built-in at all outputs. Adjustability: Available at VO1, 2,3 & 4. Output Trim: Electrical trim available at VO1/2. [ADJ #]. Remote Sensing: Available at VO1,VO2 & VO3. Hot-Swap: Available. N+1 Redundancy: Installed with internal OR-ing diodes at all outputs and third-wire current sharing method for N+1 redundancy operation. Current Sharing: Third-wire current sharing at VO1,2 & 3. DC OK Signal: Available for all outputs. Power OK Signal: Available for all outputs. Over Current Protection (OCP): Installed at each rail. Overload Protection (OLP): Fully protected against output overload or short circuit. Typ. 120-130% max. load. Consult the factory for special OLP setting. GENERAL SPECIFICATION Efficiency: Typ. 77-80 %. Switching Frequency: 120K Hz. Circuit Topology: Forward circuit. Transient Response: Peak transient less than 250mV and returns to within 1% less than 0.5ms for 50% load-change. Safety Standard: IEC60950. Construction: Eurocard 6U X 8HP X 160mm CompactPCI format. Front Panel with Extractor handle. Operating Temperature: -30 to +50 °C at full load with specified air flow. Derates linearly to 50% at +70 °C. Storage Temperature: -30 to +85 °C. Temperature Coefficient: Typ. ±0.04% / °C. Cooling: At least 800lfm moving air is required to achieve full rating power 500W in a confined area. Power Density: 5.0 Watts/ Cubic Inch. Remark: All measurements are at nominal input, full load and +25°C unless otherwise specified. OUTPUT VOLTAGE/CURRENT RATINGS CHART QUAD OUTPUT MAIN +VO1 @★#≡⊙ MODEL NO. HAC500P-490 AUX. +VO2 ▲@★#≡⊙ Min. Typ. Volt. Max. Min. 4.0A 50A +5V 60A 0A Typ. AUX. +VO3 ▲≡#⊙★@ AUX. –VO4 @▲⊙★ Volt. Max. Min. Typ. Volt. Max. Pk. Min. Typ. Volt. Max. Pk. 30A +3.3V 60A 0A 10A +12V 14A 15A 0A 3A -12V 4A 5A Symbol: "★" OVP built-in. "@" Adjustable. "#" Remote sensing. "≡" 3rd-wire Load Sharing. "⊙" Installed with Or-ing diode. "▲" Magnetic Amplifier. "●" Installed with Post-regulator. . Remark: Peak load less than 60sec. with duty cycle <10%. Max. load is the continuous operating load of each rail. But the max. load of each rail can't be drawn from all outputs at the same time. MECHANICAL DIMENSIONS: MM [INCHES] WEIGHT: 1.7kg (3.75 lb.) INPUT & OUTPUT CONNECTORS PIN ASSIGNMENT ASSIGNMENT AC INPUT L N G CNTR &PIN # 47 46 45 QUAD OUTPUT VO1 S+ S- Adj. C.S. 1,2, 3,4 Mating connector: PCIH47F400A1. 30 34 29 35 VO2 13,14, 15,16, 17,18 STATUS/CONTROL S+ Adj. C.S. VO3 33 32 41 20 S+ C.S VO4 DC COM EN# DEG# INH# FAL# 5,6,7,8,9, 36 44 21 10,11,12, 27 38 39 42 19,24