Frontier Electronics Corp. 667 E. COCHRAN STREET, SIMI VALLEY, CA 93065 TEL: (805) 522-9998 FAX: (805) 522-9989 E-mail: [email protected] Web: http://www.frontierusa.com 10A FAST EFFICIENT GLASS PASSIVATED RECTIFIER FEF100-02 THRU FEF100-06 CASE : ITO-220AC( FEF100-XX ), FULLY INSULATED PACKAGE B O J C K B C D E F G H I J K L M O D 1 2 F H E M I G PIN 1 FEATURES z GLASS PASSIVATED CHIP JUNCTION z LOW FORWARD VOLTAGE z LOW THERMAL RESISTANCE z HIGH CURRENT CAPABILITY z HIGH VOLTAGE MILLIMETERS MIN MAX 9.72 10.27 6.30 6.90 14.50 15.50 13.00 13.80 4.1 4.95 5.20 1.52 0.9 4.8 3.1 2.5 2.9 0.8 Ø 3.4 L PIN 2 CASE MECHANICAL DATA z CASE: TRANSFER MOLDED z TERMINAL: MIL-STD-202F METHOD 2026 z POLARITY: AS MARKED z EPOXY: UL94V-0 FLAME RETARDANT MOLDING COMPOUND z WEIGHT 1.81 GRAMS MAXIMUM RATINGS AND ELECTRICAL CHARACTERISTICS RATINGS AT 25°C AMBIENT TEMPERATURE UNLESS OTHERWISE SPECIFIED SINGLE PHASE, HALF WAVE, 60 HZ, RESISTIVE OR INDUCTIVE LOAD. FOR CAPACITIVE LOAD, DERATE CURRENT BY 20% RATINGS SYMBOL FEF100-02 FEF100-04 FEF100-06 UNITS MAXIMUM RECURRENT PEAK REVERSE VOLTAGE MAXIMUM RMS VOLTAGE VRRM 200 400 600 V VRMS 140 280 420 V MAXIMUM DC BLOCKING VOLTAGE MAXIMUM AVERAGE FORWARD RECTIFIED CURRENT SEE FIG.1 PEAK FORWARD SURGE CURRENT, 8.3ms SINGLE HALF SINE-WAVE SUPERIMPOSED ON RATED LOAD TYPICAL JUNCTION CAPACITANCE (NOTE 1) TYPICAL THERMAL RESISTANCE (NOTE 2) VDC IO 200 400 10.0 600 V A STORAGE TEMPERATURE RANGE OPERATING TEMPERATURE RANGE TOP IFSM 80 A CJ 65 PF Rθjc 2.2 ℃/W TSTG - 55 TO + 150 ℃ - 55 TO + 150 ℃ ELECTRICAL CHARACTERISTICS (AT TA =25°C UNLESS OTHERWISE NOTED) CHARACTERISTICS SYMBOL FEF100-02 MAXIMUM FORWARD VOLTAGE AT Io PER LEG VF 0.98 MAXIMUM DC REVERSE CURRENT AT TA=25°C IR MAXIMUM DC REVERSE CURRENT AT TA=100°C IR MAXIMUM REVERSE RECOVERY TIME (NOTE 3) TRR NOTES: 1. MEASURED AT 1 MHZ AND APPLIED REVERSE VOLTAGE 0F 4.0 VOLTS 2. THERMAL RESISTANCE JUNCTION TO CASE PER LEG MOUNTED ON HEAT SINK 3. REVERSE RECOVERY TEST CONDITIONS: IF=0.5A, IR=1.0A, IRR=0.25A FEF100-02 THRU FEF100-06 FEF100-04 FEF100-06 UNITS 1.25 10 100 25 1.90 V μA μA nS Page: 1 RATINGS AND CHARACTERISTIC CURVES FEF100-02 THRU FEF100-06 FIG. 1 -TEST CIRCUIT DIAGRAM AND REVERSE RECOVERY TIME CHARACTERISTIC 50Ω NO INDUCTIVE 10Ω NO INDUCTIVE Trr (-) +0.5A D.U.T. PULSE GENERATOR ( NOTE 2 ) (+) 25 Vdc (approx) 1Ω NON INDUCTIVE (-) OSCILLOSCOPE ( NOTE 1 ) 0 -0.25A (+) -1.0A NOTE: 1. RISE TIME=7ns MAX. INPUT IMPEDANCE=1 MOhms 22PF 2. RISE TIME =10 ns MAX. SOURCE IMPEDANCE=50 OHMS 1cm SET TIME BASE FOR 10/20 ns/cm FIG. 3 -TYPICAL INSTANTANEOUS FORWARD CHARACTERISTICS FIG. 2 -TYPICAL FORWARD CURRENT DERATING CURVE AVERAGE FORWARD CURRENT (A) 20 16 12 8 4 Single Phase Half Wave 60Hz Resistive or Inductive Load 0 25 50 75 100 125 150 175 INSTANTANEOUS FORWARD CURRENT (A) 100 10 FEF100-02 1.0 FEF100-06 .1 FEF100-04 .01 0 .2 .6 .8 1.0 1.2 1.4 1.6 1.8 FIG. 5 -TYPICAL JUNCTION CAPACITANCE FIG. 4 -TYPICAL REVERSE CHARACTERISTICS 200 1000 JUNCTION CAPACITANCE (pF) INSTANTANEOUS REVERSE CURRENT (uA) .4 INSTANTANEOUS FORWARD VOLTAGE (V) CASE TEMPERATURE (oC) 100 10 o TJ=125 C TJ=80oC 1 TJ=25oC 0.1 100 40 20 TJ=25oC 10 6 4 2 1 20 40 60 80 100 120 140 PERCENT OF RATED PEAK REVERSE VOLTAGE (%) .1 .2 .4 1.0 2 4 10 20 40 REVERSE VOLTAGE (V) FEF100-02 THRU FEF100-06 Page: 2 100