TFS70F1 - Vectron International

tfs70f1.doc
Version 2.4
VI TELEFILTER
1.
Filter Specification
09.04.2001
TFS 70 F1
1/5
Measurement condition :
Ambient temperature TA:
Input power level:
Terminating impedances at fc:
25 °C
0 dBm.
for input:
for output:
56 Ω  -30 pF.
56 Ω  -30 pF.
2. Characteristics :
Remark:
Reference level for the relative attenuation arel of the TFD 70F1 is the minimum of the pass band attenuation amin. The minimum of the pass band
attenuation amin is defined as the insertion loss ae. The reference frequency fc is the arithmetic mean value of the upper and lower frequencies at
the 3 dB filter attenuation level relative to the insertion loss ae. The temperature coefficient of frequency Tcf is valid both for the reference frequency
fc and the frequency response of the filter in the operating temperature range. The frequency shift of the filter in the operating temperature range is
not included in the production tolerance scheme.
Data
typ. value
Insertion loss (Reference level)
ae
Reference frequency fc at ambient temperature (fCTA)
tolerance / limit
22,5 dB
max.
70
70 ± 0,10MHz
MHz
Pass band ( PB ) at ambient temperature TA:
0,5 dB
Bandwidth at ambient temperature :
1 dB - band width
3 dB - band width
40 dB - band width
45 dB - band width
50 dB - band width
fc
fc
fc
fc
fc
fc
fc
fc
± 6,1
± 6,2
arel
MHz
MHz
±
±
±
±
±
±
MHz*)
MHz*)
MHz
MHz
MHz*)
MHz
6,8
7,2
8
10,2
18,2
35
max. 1,0dB
12,24
12,45
MHz
MHz
min.
min.
12,2 MHz
12,4 MHz
13,23
13,30
13,32
MHz
MHz
MHz
max.
13,3 MHz
45
48
52
55
45
45
max.
max.
1
3
dB
dB
dB
dB
dB
dB
dB
dB
min.
min.
min.
min.
min.
min.
40
45
48
50
40
40
dB
dB
dB
dB
dB
dB
max.
4,5 µs
max. 200
ns
Group delay ( mean value in PB )
Group delay ripple (p-p):
fc ... fc ± 6 MHz
Deviation from linear phase (p-p): fc ... fc ± 6 MHz
4,1
100
7,5°
µs
ns
(p-p)
Triple transit attenuation compared to main signal
Input/Output return loss with matching network (S11/S22):
Crosstalk
52
4 / 3,5
65
dB
dB
dB
Substrate material
Temperature coefficient of frequency ( Tcf )
Frequency deviation of fc over temperature
Operating temperature range
Storage temperature range
dB
fC - 6,1 MHz .... fC + 6,1 MHz
Amplitude ripple in PB (p-p):
Relative attenuation
fc .....
fc ± 6,1 MHz
fc ± 6,65 MHz
fc ± 6,8 MHz
fc ± 7,2 MHz
fc ± 8
MHz
fc ± 10,2 MHz
fc ± 18,2 MHz
25
LiNbO3
-86
ppm/K
-94
ppm/K
∆fc(Hz) = Tcf(ppm/K) x (T - TA) x fCTA (MHz)
- 25 °C ... + 80 °C
- 40 °C ... + 85 °C
*) in this frequency range the limit line is of type SLOPING LINE
Generated:
Dunzow W.P.
Checked/Approved:
Dr. Bert Wall
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
Vectron International, Inc.
267 Lowell Road
Hudson, NH 03051 / USA
Tel: (603) 598-0070 Fax: (603) 598-0075
Email: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as
a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
tfs70f1.doc
Version 2.4
VI TELEFILTER
Filter Specification
TFS 70 F1
09.04.2001
2/5
3. Package :
35 Max
TFS
tft
20,5 Max
70F1
N08
Datecode:
L
M
N
....
Year+week
1999
2000
2001
........
5,5
5,5
1
12
24
13
Pin 23
Input
Pin 24
Input RF return
Pin 11
Output
Pin 12
Output RF return
Pin 4-9, 16-21
Package ground
Pin 1-3, 10, 13-15, 22
Dummy
15,24
2,54
11x2,54 = 27,94
4. 50 Ω matching network:
1
11 12
L2
L1
24 23
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
13
Vectron International, Inc.
267 Lowell Road
Hudson, NH 03051 / USA
Tel: (603) 598-0070 Fax: (603) 598-0075
Email: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as
a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
tfs70f1.doc
Version 2.4
VI TELEFILTER
Filter Specification
09.04.2001
TFS 70 F1
3/5
5. Stability characteristics :
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 18 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Damp heat:
(cycle)
25 °C to 55°C / 95% r.H. / 10 cycles
DIN IEC 68 - 2 – 30 Db
4. Resistance to
solder heat (reflow):
max. 2 times reflow process;
for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4;
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
Vectron International, Inc.
267 Lowell Road
Hudson, NH 03051 / USA
Tel: (603) 598-0070 Fax: (603) 598-0075
Email: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as
a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
tfs70f1.doc
Version 2.4
VI TELEFILTER
Filter Specification
09.04.2001
TFS 70 F1
4/5
6. Air reflow temperature conditions :
1st and 2nd air reflow profile
Name:
Temperature:
Time:
pre-heating periods main-heating periods
150 °C - 170 °C
over 200 °C
60 sec. - 90 sec.
20 sec. - 25 sec.
peak temperature
255 °C ± 5 °C
Air reflow profile
260
240
220
200
temperature / °C
180
160
140
120
100
80
60
40
20
0
0
20
40
60
80
100
120
140
160
180
200
220
240
time / sec.
Table for temperature vs. time during the air reflow process
Tolerance of temperatures: ± 5 °C
time / sec.
0
10
20
30
40
50
60
70
80
90
100
110
120
130
temperature / °C
23
34
46
60
80
103
121
134
143
150
154
156
158
159
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
time / sec.
140
150
160
170
180
190
195
200
205
210
215
220
230
240
temperature / °C
160
161
164
170
180
205
230
255
230
205
180
165
140
120
Vectron International, Inc.
267 Lowell Road
Hudson, NH 03051 / USA
Tel: (603) 598-0070 Fax: (603) 598-0075
Email: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as
a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
tfs70f1.doc
Version 2.4
VI TELEFILTER
Filter Specification
TFS 70 F1
09.04.2001
5/5
7. History :
Version
Reason of Changes
Name
Date
2.4
Generate filter specification in actually format.
- change package;
- add ” 5. Sability characteristics ”;
Dunzow W.
09.04.2001
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
Vectron International, Inc.
267 Lowell Road
Hudson, NH 03051 / USA
Tel: (603) 598-0070 Fax: (603) 598-0075
Email: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as
a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.