Download

2.03
5th Generation Full Gate CSTBTTM IPMs (V1-Series)
Features
2
r Low loss by 5th Generation Full Gate CSTBTTM Chip
– for 600V modules:
VCE(sat) (@Tj = 125°C) = 1.90V
– for 1200V modules:
VCE(sat) (@Tj = 125°C) = 1.85V
r Optimized thermal sensor on chip
r Significantly improved power cycling capability 6Tj
(wire bond fatigue) by new wire bonding technology
r Mechanical compatibility with previous V-Series Small Package
r Short circuit protection (SC)
r Control supply under voltage protection (UV)
r Over temperature (OT) protection
(on chip temperature sensor)
r Fault signal output in case of a failure (FO)
28
2.03
5th Generation Full Gate CSTBTTM IPMs (V1-Series)
Line-up V1-Series
Symbol
Circuit
Diagram
VCES
(V)
IC (A)
200
300
400
600
450
600
PM400DV1A060
PM600DV1A060
D
1200
PM200DV1A120
Maximum
Ratings
Type Number
VCES
(V)
IC
(A)
PM300DV1A120
Thermal Characteristics
Electrical Characteristics
VCE(sat)
@ Tj = 25°C
(V)
Typ.
Max.
Maximum Switching Times
@ Tj = 125°C
ton
(μs)
tc(on)
(μs)
toff
(μs)
PM450DV1A120
tc(off)
(μs)
trr
(μs)
IGBT
Rth(j-c)
(°C/W)
Diode
Rth(j-c)
(°C/W)
Rth(c-f)
(°C/W)
Max.
Max.
Protection Functions
SC
(A)
OT
(°C)
UV
(V)
Typ.
Min.
Min.
Typ.
PackageNo.
600 Volt IPM (V1-Series)
PM400DV1A060
600
400
1.90
2.35
0.8
0.4
1.0
0.3
0.4
0.099
0.153
0.018
600
135
12
V1
PM600DV1A060
600
600
1.90
2.35
0.8
0.4
1.0
0.3
0.4
0.073
0.109
0.018
100
135
12
V1
1200 Volt IPM (V1-Series)
PM200DV1A120
1200
200
1.65
2.15
0.8
0.4
2.4
0.4
0.3
0.09
0.146
0.018
300
135
12
V1
PM300DV1A120
1200
300
1.65
2.15
0.8
0.4
2.4
0.4
0.3
0.07
0.107
0.018
450
135
12
V1
PM450DV1A120
1200
450
1.65
2.15
0.8
0.4
2.4
0.4
0.3
0.056
0.079
0.018
675
135
12
V1
Package V1
2
Circuit Diagram
29
2.04
5th Generation Full Gate CSTBTTM IPMs (L1 & S1-Series)
Applications
r UPS
r Commercial Air-Conditioner
r General Purpose Drives
2
Features
r 5th Generation IGBT chip with
Full Gate CSTBTTM resulting low power loss
r Better trade off between VCE(sat) and Eoff
Typical VCE(sat) @ 125°C: 1.75V (600V) and 1.85V (1200V)
r Package compatibility with existing range of
L-Series IPM
r New small package for 7 in 1, 50A/600V and
25A/1200V (Reduced package size by 32% of existing
L-Series IPM)
r Improved Power cycling capability
r Detection, protection and status indication for SC, OT
(with On-chip temperature sensor) & UV
r Available from 25A to 150A/1200V and 50A to 300A/600V
r Up to 75A (1200V) and 150A (600V), Solder pin & screw
types with same package foot size
r Newly developed L1-Series evaluation board is available
on request
30
2.04
5th Generation Full Gate CSTBTTM IPMs (L1 & S1-Series)
Line-up L1-Series
Symbol
Internal Function
C
3 Ø Inverter IGBT
Integrated Gate Drive
SC / OT / UV
VCES
(V)
IC (A)
25
600
1200
PM25CL1A120
PM25CL1B120
50
R
3 Ø Inverter IGBT
Integrated Gate Drive
SC / OT / UV
150
200
300
PM75CL1A060 PM100CL1A060 PM150CL1A060
PM200CL1A060 PM300CL1A060
PM75CL1B060 PM100CL1B060 PM150CL1B060
PM50CL1A120
PM50CL1B120
PM75CL1A120
PM100CL1A120 PM150CL1A120
PM75CL1B120
PM50RL1B060
PM50RL1C060
PM25RL1A120
1200 PM25RL1B120
PM25RL1C120
100
PM50CL1A060
PM50CL1B060
PM50RL1A060
600
75
PM50RL1A120
PM50RL1B120
PM75RL1A060 PM100RL1A060 PM150RL1A060
PM200RL1A060 PM300RL1A060
PM75RL1B060 PM100RL1B060 PM150RL1B060
PM75RL1A120
PM100RL1A120 PM150RL1A120
PM75RL1B120
Line-up S1-Series
Symbol
Internal Function
C
3 Ø Inverter IGBT
Integrated Gate Drive
SC / OT / UV
VCES
(V)
600
IC (A)
25
50
PM50CS1D060
1200 PM25CS1D120 PM50CS1D120
CLA / RLA types with screw terminals; CLB / RLB types with solder pins
Structure of L1-series IPM
75
100
150
200
300
PM75CS1D060 PM100CS1D060 PM150CS1D060 PM200CS1D060
PM75CS1D120 PM100CS1D120
SC: short-circuit prot. / OT: over-temperature prot. / UV: under-voltage lock prot.
Internal configuration L1/S1 series IPM
2
31
2.04
5th Generation Full Gate CSTBTTM IPMs (L1 & S1-Series)
Maximum
Ratings
Type Number
VCES
(V)
IC
(A)
VCE(sat)
@ Tj = 25°C
(V)
Typ.
2
Max.
Maximum Switching Times
@ Tj = 125°C
ton
(μs)
tc(on)
(μs)
PM50CL1A060
PM50CL1B060
PM50RL1A060
PM50RL1B060
PM50RL1C060
PM75CL1A060
PM75CL1B060
PM75RL1A060
PM75RL1B060
PM100CL1A060
PM100CL1B060
PM100RL1A060
PM100RL1B060
PM150CL1A060
PM150CL1B060
PM150RL1A060
PM150RL1B060
PM200CL1A060
PM200RL1A060
PM300CL1A060
PM300RL1A060
600
600
600
600
600
600
600
600
600
600
600
600
600
600
600
600
600
600
600
600
600
50
50
50
50
50
75
75
75
75
100
100
100
100
150
150
150
150
200
200
300
300
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
2.35
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
PM25CL1A120
PM25CL1B120
PM25RL1A120
PM25RL1B120
PM25RL1C120
PM50CL1A120
PM50CL1B120
PM50RL1A120
PM50RL1B120
PM75CL1A120
PM75CL1B120
PM75RL1A120
PM75RL1B120
PM100CL1A120
PM100RL1A120
PM150CL1A120
PM150RL1A120
1200
1200
1200
1200
1200
1200
1200
1200
1200
1200
1200
1200
1200
1200
1200
1200
1200
25
25
25
25
25
50
50
50
50
75
75
75
75
100
100
150
150
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
1.65
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
2.15
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
PM50CS1D060
PM75CS1D060
PM100CS1D060
PM150CS1D060
PM200CS1D060
600
600
600
600
600
50
75
100
150
200
1.80
1.80
1.80
1.80
1.90
2.40
2.40
2.40
2.40
2.60
0.8
0.8
0.8
0.8
0.8
0.4
0.4
0.4
0.4
0.4
PM25CS1D120
PM50CS1D120
PM75CS1D120
PM100CS1D120
1200
1200
1200
1200
25
50
75
100
1.65
1.65
1.65
1.65
2.15
2.15
2.15
2.15
0.65
0.65
0.65
0.65
0.35
0.35
0.35
0.35
toff
(μs)
tc(off)
(μs)
trr
(μs)
IGBT
Rth(j-c)
(°C/W)
Diode
Rth(j-c)
(°C/W)
Rth(c-f)
(°C/W)
Max.
Max.
600 Volt IPM (L1-Series)
0.44
1.0
0.3
0.4
1.0
0.3
0.4
0.44
1.0
0.3
0.4
0.44
1.0
0.3
0.4
0.44
1.0
0.3
0.4
0.74
1.0
0.3
0.4
0.37
1.0
0.3
0.4
0.37
1.0
0.3
0.4
0.37
1.0
0.3
0.4
0.37
1.0
0.3
0.4
0.32
1.0
0.3
0.4
0.32
1.0
0.3
0.4
0.32
1.0
0.3
0.4
0.32
1.0
0.3
0.4
0.25
1.0
0.3
0.4
0.25
1.0
0.3
0.4
0.25
1.0
0.3
0.4
0.25
1.0
0.3
0.4
0.20
1.0
0.3
0.4
0.20
1.0
0.3
0.4
0.15
1.0
0.3
0.4
0.15
1200 Volt IPM (L1-Series)
1.2
0.4
0.3
0.97
1.2
0.4
0.3
0.97
1.2
0.4
0.3
0.97
1.2
0.4
0.3
0.97
1.5
0.4
0.3
0.70
1.2
0.4
0.3
0.27
1.2
0.4
0.3
0.27
1.2
0.4
0.3
0.27
0.27
1.2
0.4
0.3
0.21
1.2
0.4
0.3
1.2
0.4
0.3
0.21
1.2
0.4
0.3
0.21
1.2
0.4
0.3
0.21
0.19
1.2
0.4
0.3
0.19
1.2
0.4
0.3
0.15
1.2
0.4
0.3
1.2
0.4
0.3
0.15
600 Volt IPM (S1-Series)
1.4
0.3
0.3
0.40
1.4
0.3
0.3
0.33
0.28
1.4
0.3
0.3
0.21
1.4
0.3
0.3
0.18
1.4
0.3
0.3
1200 Volt IPM (S1-Series)
1.1 0.35 0.2
0.37
1.1 0.35 0.2
0.25
0.20
1.1 0.35 0.2
1.1 0.35 0.2
0.18
SC: short-circuit prot. / OT: over-temperature prot. / UV: under-voltage lock prot.
32
Thermal Characteristics
Electrical Characteristics
Protection Functions
PackageNo.
SC
(A)
OT
(°C)
UV
(V)
Max.
Min.
Min.
Typ.
0.75
0.75
0.75
0.75
1.28
0.63
0.63
0.63
0.63
0.52
0.52
0.52
0.52
0.41
0.41
0.41
0.41
0.30
0.30
0.23
0.23
0.038
0.038
0.038
0.038
0.085
0.038
0.038
0.038
0.038
0.038
0.038
0.038
0.038
0.038
0.038
0.038
0.038
0.023
0.023
0.023
0.023
100
100
100
100
100
150
150
150
150
200
200
200
200
300
300
300
300
400
400
600
600
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
L1
L2
L1
L2
L5
L1
L2
L1
L2
L1
L2
L1
L2
L1
L2
L1
L2
L3
L3
L3
L3
1.60
1.60
1.60
1.60
1.18
0.47
0.47
0.47
0.47
0.36
0.36
0.36
0.36
0.31
0.31
0.23
0.23
0.038
0.038
0.038
0.038
0.085
0.038
0.038
0.038
0.038
0.038
0.038
0.038
0.038
0.023
0.023
0.023
0.023
50
50
50
50
50
100
100
100
100
150
150
150
150
200
200
300
300
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
135
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
L1
L2
L1
L2
L5
L1
L2
L1
L2
L1
L2
L1
L2
L3
L3
L3
L3
0.68
0.55
0.46
0.35
0.27
0.046
0.046
0.046
0.046
0.046
75
112
150
225
300
135
135
135
135
135
12
12
12
12
12
S1
S1
S1
S1
S1
0.59
0.41
0.32
0.27
0.046
0.046
0.046
0.046
38
75
112
150
135
135
135
135
12
12
12
12
S1
S1
S1
S1
2.04
5th Generation Full Gate CSTBTTM IPMs (L1 & S1-Series)
Package L1
Package L2
Package L3
Package L5
2
Package S1
Dimensions in mm
33
2.05
5th Generation CSTBTTM IPMs (L-Series)
Features
r 5th Generation IGBT chip with CSTBTTM
technology and 1μm design rule process
r Typical VCE(sat) =
1.5V @ Tj = 125°C for 600V and
1.9V @ Tj = 125°C for 1200V
r Integrated turn-on speed controller circuit
optimises EMI performance
r On-chip temperature sensor for Tj detection of
CSTBTTM chip
r Package size reduced by 32% compared to
previous generation
r Detection, protection and status indication
circuits for short-circuit, over-temperature,
and under-voltage (fault output available
from upper arm devices)
r Monolithic gate drive & protection logic
r Up to 75A, solder pin & screw types
with same base plate dimension
2
Line-up L-Series
Symbol
Internal
Function
VCES
(V)
IC (A)
25
50
75
PM50CLA060 PM75CLA060
150
200
300
400
600
C
PM100CLA060 PM150CLA060 PM200CLA060 PM300CLA060 PM450CLA060 PM600CLA060
600
3 Ø Inverter IGBT
PM50CLB060 PM75CLB060
Integrated Gate Drive
PM25CLA120 PM50CLA120 PM75CLA120
SC / OT / UV
PM100CLA120 PM150CLA120 PM200CLA120 PM300CLA120 PM450CLA120
1200
PM25CLB120 PM50CLB120 PM75CLB120
R
3 Ø Inverter IGBT
Integrated Gate Drive
Brake Control
SC / OT / UV
600
1200
PM50RLA060 PM75RLA060
PM50RLB060 PM75RLB060
PM100RLA060 PM150RLA060 PM200RLA060 PM300RLA060
PM25RLA120 PM50RLA120 PM75RLA120
PM100RLA120 PM150RLA120
PM25RLB120 PM50RLB120 PM75RLB120
CLA / RLA types with screw terminals; CLB / RLB types with solder pins
SC: short-circuit prot. / OT: over-temperature prot. / UV: under-voltage lock prot.
34
100
compatible to new L1-series
2.05
5th Generation CSTBTTM IPMs (L-Series)
Maximum
Ratings
Type Number
VCES
(V)
IC
(A)
VCE(sat)
@ Tj = 25°C
(V)
Typical Switching Times
@ Tj = 125°C
Typ.
Max.
ton
(μs)
tc(on)
(μs)
toff
(μs)
Typical Protection
Functions
Thermal Characteristics
Electrical Characteristics
tc(off)
(μs)
trr
(μs)
IGBT
Rth(j-c)
(°C/W)
Max.
Diode
Rth(j-c)
(°C/W)
Max.
Rth(c-f)
(°C/W)
Max.
SC
(A)
Min.
OT
(°C)
Min.
UV
(V)
Typ.
PackageNo.
600 Volt IPM (L-Series)
PM50CLA060
600
50
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.95
1.61
0.038
100
135
12
L1
PM50CLB060
600
50
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.95
1.61
0.038
100
135
12
L2
PM50RLA060
600
50
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.95
1.61
0.038
100
135
12
L1
PM50RLB060
600
50
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.95
1.61
0.038
100
135
12
L2
PM75CLA060
600
75
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.32
0.53
0.038
150
135
12
L1
PM75CLB060
600
75
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.32
0.53
0.038
150
135
12
L2
PM75RLA060
600
75
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.32
0.53
0.038
150
135
12
L1
PM75RLB060
600
75
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.32
0.53
0.038
150
135
12
L2
PM100CLA060
600
100
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.27
0.43
0.038
200
135
12
L1
PM100RLA060
600
100
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.27
0.43
0.038
200
135
12
L1
PM150CLA060
600
150
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.20
0.33
0.038
300
135
12
L1
PM150RLA060
600
150
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.20
0.33
0.038
300
135
12
L1
PM200CLA060
600
200
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.16
0.25
0.023
400
135
12
L3
PM200RLA060
600
200
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.16
0.25
0.023
400
135
12
L3
PM300CLA060
600
300
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.12
0.19
0.023
600
135
12
L3
PM300RLA060
600
300
1.6
2.1
1.0
0.4
1.2
0.5
0.2
0.12
0.19
0.023
600
135
12
L3
PM450CLA060
600
450
1.7
2.2
1.0
0.4
2.2
0.6
0.2
0.12
0.19
0.014
900
135
12
L4
PM600CLA060
600
600
1.7
2.2
1.0
0.4
2.2
0.6
0.2
0.07
0.11
0.014
1200
135
12
L4
PM25CLA120
1200
25
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.83
1.36
0.038
50
135
12
L1
PM25CLB120
1200
25
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.83
1.36
0.038
50
135
12
L2
PM25RLA120
1200
25
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.83
1.36
0.038
50
135
12
L1
PM25RLB120
1200
25
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.83
1.36
0.038
50
135
12
L2
PM50CLA120
1200
50
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.26
0.39
0.038
100
135
12
L1
PM50CLB120
1200
50
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.26
0.39
0.038
100
135
12
L2
PM50RLA120
1200
50
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.26
0.39
0.038
100
135
12
L1
PM50RLB120
1200
50
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.26
0.39
0.038
100
135
12
L2
PM75CLA120
1200
75
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.21
0.30
0.038
150
135
12
L1
PM75CLB120
1200
75
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.21
0.30
0.038
150
135
12
L2
PM75RLA120
1200
75
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.21
0.30
0.038
150
135
12
L1
PM75RLB120
1200
75
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.21
0.30
0.038
150
135
12
L2
PM100CLA120
1200
100
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.16
0.26
0.023
200
135
12
L3
PM100RLA120
1200
100
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.16
0.26
0.023
200
135
12
L3
PM150CLA120
1200
150
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.12
0.20
0.023
300
135
12
L3
PM150RLA120
1200
150
1.8
2.3
1.0
0.4
2.0
0.7
0.5
0.12
0.20
0.023
300
135
12
L3
PM200CLA120
1200
200
1.8
2.3
1.0
0.4
2.3
0.7
0.5
0.12
0.20
0.014
400
135
12
L4
PM300CLA120
1200
300
1.8
2.3
1.0
0.4
2.3
0.7
0.5
0.08
0.13
0.014
600
135
12
L4
PM450CLA120
1200
450
1.8
2.3
1.0
0.4
2.3
0.7
0.5
0.05
0.09
0.014
900
135
12
L4
1200 Volt IPM (L-Series)
2
SC: short-circuit prot. / OT: over-temperature prot. / UV: under-voltage lock prot.
35
2.05
5th Generation CSTBTTM IPMs (L-Series)
Package L1
Package L2
Package L3
Package L4
2
Dimensions in mm
36