Embedded Power for Business-Critical Continuity DC Input DS450DC-3/ DS550DC-3 450 - 550 Watts Distributed Power System Distributed Power Bulk Front-End Total Output Power: 450 - 550 Watts +12 Vdc main Output +3.3 Vdc Stand-by Output DC Input 36 - 75 Vdc Connector input shown Electrical Specifications Special Features Input Input range: 36 - 75 Vdc • • • • • • • • • • • • • • • • • Frequency: Inrush current: DC input 1U X 2U Form Factor 10.3 W / in3 (DS550) 8.4 W / in3 (DS450) +12 Vdc Output +3.3 Vdc Stand-By No Minimum Load Required Hot Plug Operation N + 1 Redundant Internal OR’ing Fets Active Current Sharing Built-in Cooling Fans (40 mm x 28 mm) I2C Communication Interface Bus EERPOM for FRU Data Amber LED Status, Fan_Fail Green LED Status, Power Good / DC_OK Status (VIN_GOOD) Internal Fan Speed Control Fan Fail Tach Output Signal One Year Warranty Safety • • • • • UL/cUL 60950 (UL Recognized) NEMKO+ CB Report EN60950 EN60950 CE Mark China CCC Efficiency: 21 A maximum EVT: 87% @ 72 Vdc; 87.4% @ 75 Vdc Conducted EMI: FCC Subpart J EN55022 Class A Radiated EMI: FCC Subpart J EN55022 Class A Power factor: N/A Leakage current: N/A No touch current required. Hold up time: 1 ms minimum Output Main DC voltage: +12 V Stand-By: +3.3 Vsb Adjustment range: Factory Set, no pot adjustments Regulation: +12 Vdc; +5%/-5% +3.3 Vsb; +5%/-5% Over current: See Table 1 next page Over voltage: +12 Vdc; 13.5 - 15 Vdc +3.3 Vsb; 3.76 - 4.30 Vdc Under voltage: +12 Vdc; 10.5 V - 11.0 V +3.3 Vsb; 2.77 - 3.00 Vdc < 3 seconds, EVT: 2 seconds 3 - 300 mS Turn-on delay: +12 V Output Rise Time: Rev. 10.13.09_79 DS450DC/DS550DC of 4 Embedded Power for Business-Critical Continuity Rev. 10.13.09_79 DS450DC/DS550DC of 4 Logic Control PS_ON/L: (Power supply enable) The power supply output will be enabled when this signal is pulled low (< 0.8 V). HIGH = Output V1 OFF LOW = Output V1 ON VIN_GOOD/H (Input OK): Active High signal asserted when the input voltage rises above the min input voltage specified. This signal is internally pulled up through 4.7 K ohms to the 3.3 V housekeeping voltage. POK/H (Output OK): Active High signal asserted when the output is within regulation. This signal is internally pulled up through 1.0 K ohms to the 3.3 V housekeeping voltage. TACH_1: This open collector signal generates two pulses per each fan revolution. This signal is eternally pulled up to the housekeeping voltage. PS_KILL: This signal will cause the output to shut down when drive high (> 24 V) or left floating. The PS_KILL will cause the output to latch off and requires recycle of PS_ON or DC input to reset. Digital Control: PMBus - I2C compliant Environmental Specifications Operating temperature: -10 °C to 50 °C Storage temperature: Altitude, operating: -40 °C to +70 °C 10,000 ft. Electromagnetic - EN61000-3-2, -3-3 susceptibility / Input transients: - EN61000-4-2, 4.3, 4-4, -4-5, 4-11 Level - EN55024:1998 RoHS & lead-free compliant (no tantalum caps.) Humidity: 20 to 90% RH, non-condensing Shock and vibration specificatons complies with Astec Std. Specifications, Q3205 MTBF (observed): 500K Hrs at 80%, 40 °C Ordering Information Output DS450DC-3 DS450DC-3-002 DS550DC-3 DS550DC-3-003 Nominal Output Voltage Set Point 12.0 Vdc 3.3 Vsb 12.0 Vdc 3.3 Vsb 12.0 Vdc 3.3 Vsb 12.0 Vdc 3.3 Vsb Set Point Tolerance ± 0.2% ± 1% ± 0.2% ± 1% ± 0.2% ± 1% ± 0.2% ± 1% Total Regulation +5 / -3% +5 / -4% +5 / -3% +5 / -4% +5 / -3% +5 / -4% +5 / -3% +5 / -4% Minimum Current 0A 0A 0A 0A 0A 0A 0A 0A *Over current latches off if overcurrent lasts over 1 second, otherwise it is auto recovery. *For 5 Vsb, consult marketing. Maximum Current 37.0 A 3.0 A 37.0 A 3.0 A 45.0 A 3.0 A 45.0 A 3.0 A Output Ripple P/P 120 mV 60 mV 120 mV 60mV 120 mV 60 mV 120 mV 60 mV Over Current 39.5 - 44.4% 4.9 A Avg, 7 A max 39.5 - 44.4% 4.9 A Avg, 7 A max 48.0A - 54.0A 4.9 A Avg, 7 A max 48.0A - 54.0A 4.9 A Avg, 7 A max Options Standard Reverse Air Standard Reverse Air Embedded Power for Business-Critical Continuity Rev. 10.13.09_79 DS450DC/DS550DC of 4 Mechanical Drawing A (2X) REF RAMP TO FAN 1,6 40 38,4 254,7 337,6 305,6 10 ± 0,8 276,3 254,7 (3X) LABEL 3 ± 0,3 78 11 01 (1.8) (0.7) 8 302,9 ± 0,8 STANDARD AIR FLOW DIRECTION -002 REVERSE AIR FLOW DIRECTION 07 5 ± 0,5 ± 0,5 09 01 329,4 254,6 1.25 MIN 5,8 38,4 72,2 05 ± 0,8 06 LATCHING SPRING DISTANCE (REF.) 3,8 ± 0,8 39,8 ± 0,8 04 74,1 ± 0,6 01 A 08 24,7 ± 0,5 41,5 A 326,7 78 ± 0,8 03 02 (3X) ( 80,1 ) 254,6 01 01 12 Embedded Power for Business-Critical Continuity Americas 5810 Van Allen Way Carlsbad, CA 92008 USA Telephone:+1 760 930 4600 Facsimile: +1 760 930 0698 DC Output Connector Pinout Assignment Male connector as viewed from the rear of the supply: D1 D2 D3 D4 D5 D6 C1 C2 C3 C4 C5 C6 B1 B2 B3 B4 B5 B6 A1 A2 A3 A4 A5 A6 PB1 PB2 PB3 PB4 PB5 PB6 P1 - Power Supply Side 1.FCI Power Blade 51721 series 51721-10002406AA 2.Molex Power Connector SD-87667 series 87667-7002 Mating Connector (System Side) 1.FCI Power Blade 51741-10002406CC Strait Pins 2.FCI Power Blade 51761-10002406AA Right Angle Rev. 10.13.09_79 DS450DC/DS550DC of 4 Europe (UK) Pin Signal Name PB 1 PB 2 PB 3 PB 4 PB 5 PB 6 A1 A2 A3 A4 A5 A6 B1 B2 B3 B4 B5 B6 C1 C2 C3 C4 C5 C6 D1 D2 D3 D4 D5 D6 +12 V Return +12 V Return +12 V Return +12 V +12 V +12 V PS_KILL +12 V_Current Share Return Write Protect PS A0 +3.3 V SB Return 12 V RTN Sense Return +3.3 V SB SDA -PS_ON/L Return Tach_1 Return +3.3 V SB SCL VIN_GOOD/H -Present/L +12 V_Sense Return +3.3 V SB Alert/L (S_INT) POK/H (PWROK/H) Waterfront Business Park Merry Hill, Dudley West Midlands, DY5 1LX United Kingdom Telephone:+44 (0) 1384 842 211 Facsimile: +44 (0) 1384 843 355 Asia (HK) 14/F, Lu Plaza 2 Wing Yip Street Kwun Tong, Kowloon Hong Kong Telephone:+852 2176 3333 Facsimile: +852 2176 3888 For global contact, visit: www.PowerConversion.com techsupport.embeddedpower @emerson.com While every precaution has been taken to ensure accuracy and completeness in this literature, Emerson Network Power assumes no responsibility, and disclaims all liability for damages resulting from use of this information or for any errors or omissions. Emerson Network Power. The global leader in enabling business-critical continuity. AC Power Connectivity DC Power Embedded Computing Embedded Power Monitoring Outside Plant Power Switching & Controls Precision Cooling Racks & Integrated Cabinets Services Surge Protection EmersonNetworkPower.com Emerson Network Power and the Emerson Network Power logo are trademarks and service marks of Emerson Electric Co. ©2009 Emerson Electric Co.