Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter FEATURES: Models Single output • Constant Current or Constant Voltage LED Driver or Converter • Input range 90-305VAC/47-440Hz • High Efficiency up to 91% • 115VAC Operating temperature -50 to 80°C • 230VAC Operating temperature -55 to 80°C • Dimmable via analog / 0-10V dimming ② Output Voltage Range ③ (V) Output Current ③ (A) Input Voltage (VAC/Hz) Input Voltage (VDC) 150 36-50 0-3 90-305/47-440 120-430 AMER150-36420CAZ 150 24-36 0-4.16 90-305/47-440 120-430 AMER150-24630CAZ 151.2 12-24 0-6.3 90-305/47-440 120-430 Model AMER150-50300CAZ Max Output Power (W) ① • • • • • Over Voltage Protection Over Current Protection Waterproof Case rated IP68 Power Factor Correction Short Circuit Protection Mode of Operation Constant Current Constant Voltage ② Constant Current Constant Voltage ② Constant Current Constant Voltage ② Efficiency (%) 91 90 90 88 89 87 Add Suffix “-F” No dimming option Exceeding the maximum output power will permanently damage the converter. ② The dimming feature is not supported when units are used in Constant Voltage mode only, Aimtec suggests to order “-F” No dimming option in this case. ③ In constant current mode output current is maximum shown, in constant voltage mode output voltage is the maximum shown. NOTE: All specifications in this datasheet are measured at an ambient temperature of 25°C, humidity<75%, nominal input voltage and at rated output load unless otherwise specified. ① Input Specifications Parameters Inrush current <2ms Leakage current AC current Power Factor External fuse Start up time Surge voltage Output Specifications Parameters Conditions 115VAC 230VAC 115VAC 230VAC 115VAC 230VAC 115VAC 230VAC Typical 50 75 0.75 1 2.2 0.7 900 2sec Conditions Typical Current accuracy ±3 Line regulation LL-HL ±1 Load regulation 0-100% load ±3 20MHz Bandwidth 100 Ripple & Noise ④ Hold-up time (min) 45 Current adjustment range 100-0 Minimum Load Voltage See the models table ④ Tested with 0.1µF (C/C) or (M/C) and 47µF (E/C) parallel capacitors at the end. www.aimtec.com F 052.1e R3.E Tel: +1 514 620 2722 1 of 10 Maximum Units A mA A 0.98 0.94 250V/3.5A 440 ms V Maximum Units % % % mV p-p ms % Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Isolation Specifications Parameters Tested I/P-O/P voltage Tested I/P-FG voltage Tested O/P-FG voltage Isolation Resistance Isolation Capacitance General Specifications Parameters Switching frequency Over current protection Over voltage protection Short circuit protection Short circuit restart Over temperature protection Operating temperature (See Derating Table) Cold Start-up Time Maximum case temperature Storage temperature Temperature coefficient Cooling Humidity Case material Potting Wires Weight Dimensions (L X H X W) MTBF Conditions Typical 3sec 3sec 3sec 500VDC Maximum >1000 Conditions Units 3750 1880 500 VAC VAC VAC MΩ pF 1000 Typical Maximum 100 110% of Iout 110% of Vout Continuous Auto recovery >105°C -50 to +80 -55 to +80 (115VAC) (230VAC) -55°C Units KHz o 20 100 C C Sec o C o C % / oC 95 % RH o -55 to +95 ±0.02 Free air convection Aluminum Epoxy (IP68 rated) UL1015 18AWG Input & 14AWG Output *20CM 750 7.13 x 2.32 x 1.85 inches 181.00 x 59.00 x 47.00 mm >400,000 hrs (MIL-HDBK-217F at +25°C) g Safety Specifications Parameters Agency approvals Standards www.aimtec.com F 052.1e R3.E CE EN55022, class B, EN60529(IP68), EN61347-1, EN61347-2-13 NOTE: Also designed to Meet cULus, UL8750, UL60950-1 Tel: +1 514 620 2722 2 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Dimensions Top View 181.00 (7.13) 4.00 (0.16) 41.00 (1.73) 27.00 (1.06) 8.00 (0.32) 11.00 (0.43) 23.00 (0.91) End View Side View 200.00 (8.00) 47.00 (1.85) 200.00 (8.00) 59.00 (2.32) 2.30 (0.09) Input/Output Wires are 18 AWG 20cm Measurements in Millimeters (inch) Case Tolerance: ±0.5 (±0.02) Analog (resistive) Dimming Application Circuit AC BROWN L GREEN AMER150-AZ BLUE N F 052.1e R3.E 1 -Vout 1 BLUE WHITE www.aimtec.com +Vout RED 1st LED Model Number AMER150-50300CAZ AMER150-36420CAZ AMER150-24630CAZ Maximum Pot Value (kΩ) 16.71 26.70 11.47 BLACK Pot Tel: +1 514 620 2722 3 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter 0-10V Dimming Application Circuit U1 +Vs (Blue) 0-10Vdc Pin 1 -Vs (White) Pin 2 R28 1K5, 0805 LTV-817C GND Derating Free Air Convection CV mode CC Mode 50°C 50°C 100 Output Power (%) 230VAC 80 60 Safe Operating Area 40 20 80°C 0 - 55 - 30 0 20 40 60 80°C 80 100 Ambient Temperature º C www.aimtec.com F 052.1e R3.E Tel: +1 514 620 2722 4 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Efficiency vs. Input Voltage & Output Current (CC mode) AMER150-50300CAZ AMER150-36420CAZ www.aimtec.com F 052.1e R3.E Tel: +1 514 620 2722 5 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Efficiency vs. Input Voltage & Output Current (CC mode) Continued AMER150-24630CAZ PFC value vs. Output Load Current (CC mode) AMER150-50300CAZ www.aimtec.com F 052.1e R3.E Tel: +1 514 620 2722 6 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter PFC value vs. Output Load Current (CC mode) Continued AMER150-36420CAZ AMER150-24630CAZ www.aimtec.com F 052.1e R3.E Tel: +1 514 620 2722 7 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Constant Current vs. Constant Voltage Mode AMER150-50300CAZ AMER150-36420CAZ www.aimtec.com F 052.1e R3.E Tel: +1 514 620 2722 8 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Constant Current vs. Constant Voltage Mode Continued AMER150-24630CAZ Output Current vs. Radj AMER150-50300CAZ www.aimtec.com F 052.1e R3.E Tel: +1 514 620 2722 9 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only Series AMER150-CAZ up to 6.3A | AC-DC / DC-DC | LED Driver / Converter Output Current vs. Radj Continued AMER150-36420CAZ AMER150-24630CAZ NOTE: 1. Datasheets are updated as needed and as such, specifications are subject to change without notice. Once printed or downloaded, datasheets are no longer controlled by Aimtec; refer to www.aimtec.com for the most current product specifications. 2. Product labels shown, including safety agency certifications on labels, may vary based on the date manufactured. 3. Mechanical drawings and specifications are for reference only. 4. All specifications are measured at an ambient temperature of 25°C, humidity<75%, nominal input voltage and at rated output load unless otherwise specified. 5. Aimtec may not have conducted destructive testing or chemical analysis on all internal components and chemicals at the time of publishing this document. CAS numbers and other limited information are considered proprietary and may not be available for release. 6. This product is not designed for use in critical life support systems, equipment used in hazardous environments, nuclear control systems or other such applications which necessitate specific safety and regulatory standards other the ones listed in this datasheet. 7. Warranty is in accordance with Aimtec’s standard Terms of Sale available at www.aimtec.com. www.aimtec.com F 052.1e R3.E Tel: +1 514 620 2722 10 of 10 Toll free: + 1 888 9 AIMTEC (924 6832) North America only