Filename: tfs 150l.doc Version 1.1 VI TELEFILTER 05.09.2005 Development specification TFS 150L 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedance: * Input: Output: 23 0 °C dBm t.b.d. t.b.d. Characteristics Remark: The reference level for the relative attenuation arel of the TFS150L is the minimum of the pass band attenuation amin. The minimum of the pass band attenuation amin is defined as the insertion loss ae. The reference frequency fc is the arithmetic mean value of the upper ( f1,5dB+ ) and lower (f1,5dB-) frequencies at the 1,5 dB filter attenuation level relative to the insertion loss ae. The temperature coefficient of frequency Tcf is valid both for the reference frequency fc and the frequency response of the filter in the operating temperature range. Data typ. value ae Insertion loss (reference level) fC Centre frequency at ambient temperature PB Passband in OTR p-p Pass band ripple max. MHz 25 dB 150,0±0,1 MHz - ( BW 1,5dB ) MHz max. 1,5 dB BW 1,5 dB 1,5 dB Relative attenuation + 0,40 MHz 0,60 MHz + 0,60 MHz 1,00 MHz + 1,00 MHz 5,00 MHz + 5,00 MHz - 35,00 MHz - 100,00 MHz + 35,00 MHz 150,0 dB - Bandwidth f1,5dB+ f1,5dBf1,5dB+ f1,5dBf1,5dB+ f1,5dBf1,5dB+ f1,5dBf1,5dBf1,5dB+ 23 tolerance / limit 5,0 5,0 in OTR MHz MHz 5,0 ± 0,05 MHz 5,0 ± 0,16 MHz arel … … … … … … … … … … f1,5dB+ f1,5dBf1,5dB+ f1,5dBf1,5dB+ f1,5dBf1,5dB+ f1,5dBf1,5dBf1,5dB+ + + + + + MHz MHz MHz MHz MHz MHz MHz MHz MHz MHz mean value in PB Group delay Group delay ripple within PB 0,60 0,40 1,00 0,60 5,00 1,00 35,00 5,00 35,00 100,00 p-p - min. min. min. min. min. min. min. min. min. min. - max. - max. 20 20 30 30 39 39 47 47 50 50 3,6 150 p-p 12° Triple transit attenuation compared to main signal 46 dB - Crosstalk attenuation compared to main signal 65 dB - 6 dB Deviation from linear phase within PB Input/Output return loss within PB Operating temperature range OTR TCf ** -0,032 µs ns - 25 °C ... + 80°C - Storage temperature range Temperature coefficient of frequency - dB dB dB dB dB dB dB dB dB dB - 40 °C ... + 85°C ppm/K 2 *) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team. **) ∆f(Hz) = TCf(ppm/K) x (T-T0)2 x fTo(MHz) Generated: Checked / Approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 150l.doc Version 1.1 VI TELEFILTER 05.09.2005 Development specification TFS 150L 2/5 Filter characteristic t.b.d. Construction and pin connection TFS 150L ● T34 1 12,65 ±0,20 (All dimensions in mm) 1 2 3 4 5 6 Input Ground Output RF Return Output Ground Input RF Return Date code: T U V ... Year + week 2005 2006 2007 27,18 ±0,20 5,6±0,3 5,2 Max. Date code ø0,45±0,05 7,62 ±0,20 1 2,54 ±0,20 20,32 ±0,20 50 Ω Test circuit t.b.d. Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 150l.doc Version 1.1 VI TELEFILTER Development specification 05.09.2005 TFS 150L 3/5 Stability characteristics After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 1 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: twice max.; for temperature conditions, please refer to the attached "Air reflow temperature conditions" on page 4; Air reflow temperature conditions Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 150l.doc VI TELEFILTER Version 1.1 05.09.2005 Development specification Conditions Average ramp-up rate (30°C to 217°C) > 100°C > 150°C > 217°C Peak temperature Time within 5°C of actual peak temperature Cool-down rate (Peak to 50°C) Time from 30°C to Peak temperature TFS 150L 4/5 Exposure less than 3°C/second between 300 and 600 seconds between 240 and 500 seconds between 30 and 150 seconds max. 260°C between 10 and 30 seconds less than 6°C/second no greater than 300 seconds Chip-mount air reflow profile Temperature / °C max. 260°C 217°C max. 300 s 10 ... 30 s Time / s 30 ... 150 s Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 150l.doc VI TELEFILTER Version 1.1 Development specification 05.09.2005 TFS 150L 5/5 History Version Reason of Changes Name Date 1.0 - Generation of development specification Strehl 23.08.2005 1.1 - Temperature coefficient corrected Steiner 05.09.2005 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.