VECTRON TFS463A

Filename: tfs 463a.doc
Version 1.4
VI TELEFILTER
01.03.2005
Filter specification
TFS 463A
1/5
Measurement condition
Ambient temperature:
Input power level:
Terminating impedance: *
Input:
Output:
23
0
°C
dBm
228 Ω || -1.25 pF
228 Ω || -1.25 pF
Characteristics
Remark:
The reference level for the relative attenuation arel of the TFS 463A is the minimum of the pass band attenuation amin. The minimum of the pass band
attenuation amin is defined as the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB
filter attenuation level relative to the insertion loss ae. The nominal frequency fN is fixed at 463,7375 MHz without any tolerance. The given values for both
the relative attenuation arel and the group delay ripple have to be achieved at the frequencies given below even if the centre frequency fc is shifted due to
the temperature coefficient of frequency TCf in the operating temperature range and due to a production tolerance for the centre frequency fc.
Data
typ. value
Insertion loss
(reference level)
ae = amin
Nominal frequency
fN
Centre frequency
fC
Passband
2,8
max.
-
-
Pass band ripple
p-p
0,5
Relative attenuation
arel
4,0
dB
463,7375 MHz
463,7375 MHz
PB
400,00
432,00
dB
tolerance / limit
fN
±3,7375 MHz
dB
max.
0,75
dB
10,00
428,00
MHz
MHz
…
…
MHz
MHz
58
40
dB
dB
min.
min.
50
30
dB
dB
488,00
540,00
567,52
675,04
682,515
1200,00
MHz
MHz
MHz
MHz
MHz
MHz
… 492,00 MHz
… 567,52 MHz
… 675,04 MHz
… 682,515 MHz
… 1200,00 MHz
… 1724,98 MHz
23
58
61
60
59
74
dB
dB
dB
dB
dB
dB
min.
min.
min.
min.
min.
min.
20
40
50
55
45
30
dB
dB
dB
dB
dB
dB
20
ns
max.
40
ns
Group delay ripple within PB
Phase ripple within PB
Intermodulation
0,7
Return loss within PB
14
Input power level
Operating temperature range
dB
OTR
Storage temperature range
Temperature coefficient of frequency
° rms
Output-IP3 ****
- 74
1,6
° rms
37
dBm
min.
10
dB
max.
15
dBm
0 °C ... + 80°C
TCf **
max.
min.
- 20 °C ... + 90°C
ppm/K
-
*) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values
only. Should there be additional questions, do not hesitate to ask for an application note or contact our design team.
**) ∆f(Hz) = TCf(ppm/K) x (T0-T) x fCAT(MHz).
****) fin1= 461,7375 MHz; fin2= 462,7375 MHz; Pin= 10 dBm fmeasurement = 463,7375 MHz and fin1= ??MHz; fin2= ??MHz; Pin=??dBm fmeasurement = ??MHz.
Generated:
Checked / Approved:
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 463a.doc
Version 1.4
VI TELEFILTER
01.03.2005
Filter specification
TFS 463A
2/5
0
0.2
-1
0.18
-20
-2
0.16
-30
-3
0.14
-4
0.12
-5
0.1
-40
-50
-60
-6
0.08
-70
-7
0.06
-80
-8
0.04
-90
-9
0.02
-100
-10
200
400
600
800
1000
1200
frequency in MHz
1400
1600
1800
445
450
455
460
465
470
frequency in MHz
475
480
delay in µs
0
-10
magnitude in dB
magnitude in dB
Filter characteristic
0
Construction and pin connection
(All dimensions in mm)
463A
● T10
1
2
3
4
5
6
7
8
Ground
Input RF Return
Input
Ground
Ground
Output RF Return
Output
Ground
Date code:
T
U
V
...
Year + week
2005
2006
2007
50 Ω Test circuit
3
7
1, 2, 4, 5, 6, 8
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 463a.doc
Version 1.4
VI TELEFILTER
01.03.2005
Filter specification
TFS 463A
3/5
Stability characteristics
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 18 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Change of
temperature:
4. Resistance to
solder heat (reflow):
-55 °C to 125°C / 30 min. each / 10 cycles
DIN IEC 68 part 2 – 14 Test N
reflow possible: twice max.;
for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4;
Packing
Tape & Reel:
IEC 286 – 3, with exeption of value for N and minimum bending radius;
tape type II, embossed carrier tape with top cover tape on the upper side;
max. pieces of filters peer reel:
reel of empty components at start:
reel of empty components at start including leader:
trailer:
3000
min. 300 mm
min. 500 mm
min. 300 mm
Pull Off Direction
Tape (all dimensions in mm)
W
: 12,00 ± 0,3
Po
: 4,00 ± 0,1
Do
: 1,50 +0,1/-0
E
: 1,75 ± 0,1
F
: 5,50 ± 0,05
G(min)
: 0,75
P2
: 2,00 ± 0,05
P1
: 8,00 ± 0,1
D1(min)
: 1,50
Ao
: 5,30 ± 0,1
Bo
: 5,30 ± 0,1
Ct
: 9,5 ± 0,1
t
P1
Date Code
Po
P2
W
G
Ct
Bo
F
G
E
Do
Ko
Typ
PIN Marker
D1
Ao
W 2
Reel (all dimensions in mm)
A
: 330
W1
: 12,4 +2/-0
W2(max) : 18,4
N(min)
: 50
C
: 13,0 +0,5/-0,2
A
C
N
W 1
The minimum bending radius is 45 mm.
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 463a.doc
Version 1.4
VI TELEFILTER
01.03.2005
Filter specification
TFS 463A
4/5
Air reflow temperature conditions
Conditions
Average ramp-up rate (30°C to 217°C)
> 100°C
> 150°C
> 217°C
Peak temperature
Time within 5°C of actual peak temperature
Cool-down rate (Peak to 50°C)
Time from 30°C to Peak temperature
Exposure
less than 3°C/second
between 300 and 600 seconds
between 240 and 500 seconds
between 30 and 150 seconds
max. 260°C
between 10 and 30 seconds
less than 6°C/second
no greater than 300 seconds
Chip-mount air reflow profile
Temperature / °C
max. 260°C
217°C
max. 300 s
10 ... 30 s
Time / s
30 ... 150 s
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 463a.doc
VI TELEFILTER
Version 1.4
Filter specification
01.03.2005
TFS 463A
5/5
History
Version
Reason of Changes
Name
Date
1.0
- Generation of development specification
Strehl
04.10.2004
1.1
- fixing of minor errors
Martens
12.10.2004
1.2
- change temperature range and insertion loss
Martens
27.10.2004
1.3
- intermodulation defined more precisely
Steiner
29.10.2004
1.4
- added typical values, filter characteristic and test circuit;
generation of filter specification
Noack
01.03.2005
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.