TFS188A

Filename: tfs 188a.doc
Version 1.3
VI TELEFILTER
12.05.2005
Filter specification
TFS 188A
1/5
Measurement condition
Ambient temperature:
Input power level:
Terminating impedances at fc: *
25 °C ± 2°C
0 dBm
input:
1076 Ω ⎟⎢ - 5,8 pF
output:
831 Ω ⎟⎢ - 6,6 pF
Characteristics
Remark:
The reference level for the relative attenuation arel of TFS 188A is the minimum of the pass band attenuation amin. This value is defined as the insertion
loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB filter attenuation level relative to the insertion
loss ae. The given values for the relative attenuation arel and the group delay ripple have to be reached at the frequencies given below, even if the centre
frequency fc is shifted due to the temperature coefficient of frequency TCf in the operating temperature range and due to a production tolerance for the
centre frequency fc.
Data
typ. value
Insertion loss
(reference level)
ae
Nominal frequency
Centre frequency
fN
4,8 dB
188
fC
Relative attenuation
arel
fN
.......
fN ±
0,06
fN ± 0,06 MHz ....... fN ± 0,12
MHz
MHz
fN ±
fN ±
fN ±
MHz
MHz
MHz
0,8
1,6
3,2
MHz ....... fN ± 1,6
MHz ....... fN ± 3,2
MHz ....... fN ± 10
Absolute group delay at fN
Group delay variation in fN ± 0,12
MHz
Temperature coefficient of frequency Tcf **
max.
6
188
-
MHz
0,15 dB
0,8 dB
38
43
47
tolerance / limit
max.
max.
0,29
3
dB
MHz
dB
dB
dB
dB
dB
min.
min.
min.
35
36
40
dB
dB
dB
1,5 µs
max.
5
µs
max. 250
ns
120
ns
- 0,04 ppm/K²
-
Operating temperature range
-
- 25 °C ... + 75 °C
Storage temperature range
-
- 40 °C ... + 85 °C
35
°C
Frequency inversion temperature T0
*) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as
reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team.
**) ∆f(Hz) = TCf(ppm/K²) x (T-T0)² x fTo(MHz)
generated:
checked / approved:
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 188a.doc
Version 1.3
VI TELEFILTER
12.05.2005
Filter specification
TFS 188A
2/5
0
3.29
-1
3.08
-12
-2
2.87
-18
-3
2.66
-24
-4
2.45
-5
2.24
-6
2.03
-42
-7
1.82
-48
-8
1.61
-54
-9
1.4
-30
-36
-60
182
183.2
184.4
185.6
186.8
188
189.2
frequency in MHz
190.4
191.6
192.8
194
-10
187.5
187.6
187.7
187.8
187.9
188
188.1
frequency in MHz
188.2
188.3
188.4
delay in µs
0
-6
magnitude in dB
magnitude in dB
Filter characteristic
1.19
188.5
Construction and pin connection
5,3 Max.
(All dimensions in mm)
11,7 Max.
TFS 188A
●
T20
1
2 Max.
Date code
1
2
4
9
5
8
7
Ground
Ground
Ground
Output RF Return
Output
Ground
Ground
Ground
Input RF Return
Input
Date code:
T
U
V
...
Year + week
2005
2006
2007
3
10
5,08
0,8
2,54
1
1
2
3
4
5
6
7
8
9
10
6
50 Ω Test circuit
L1
5
10
9
SAW
L2
4
C2
C1
1, 2, 3, 6, 7, 8
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 188a.doc
Version 1.3
VI TELEFILTER
12.05.2005
Filter specification
TFS 188A
3/5
Stability characteristics
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 1 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Change of
temperature:
4. Resistance to
solder heat (reflow):
-55 °C to 125°C / 30 min. each / 10 cycles
DIN IEC 68 part 2 – 14 Test N
reflow possible: twice max.;
for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4;
Packing
Tape & Reel:
IEC 286 – 3, with exeption of value for N and minimum bending radius;
tape type II, embossed carrier tape with top cover tape on the upper side;
max. pieces of filters peer reel:
reel of empty components at start:
reel of empty components at start including leader:
trailer:
3000
min. 300 mm
min. 500 mm
min. 300 mm
Pull Off Direc tion
Tape (all dimensions in mm)
W
: 24,00 ± 0,3
Po
: 4,00 ± 0,1
Do
: 1,50 +0,1/-0
E
: 1,75 ± 0,1
F
: 11,50 ± 0,1
G(min)
: 0,60
P2
: 2,00 ± 0,1
P1
: 8,00 ± 0,1
D1(min)
: 1,50
Ao
: 5,60 ± 0,1
Bo
: 11,80 ± 0,1
Ct
: 21,5 ± 0,1
P1
Date Code
t
Po
P2
W
G
Ct
Bo
F
G
E
Do
Ko
Typ
PIN Marker
D1
Ao
W 2
Reel (all dimensions in mm)
A
: 330
W1
: 24,4 +2/-0
W2(max) : 30,4
N(min)
: 60
C
: 13,0 +0,5/-0,2
A
C
N
W 1
The minimum bending radius is 45 mm.
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 188a.doc
Version 1.3
VI TELEFILTER
12.05.2005
Filter specification
TFS 188A
4/5
Air reflow temperature conditions
Conditions
Average ramp-up rate (30°C to 217°C)
> 100°C
> 150°C
> 217°C
Peak temperature
Time within 5°C of actual peak temperature
Cool-down rate (Peak to 50°C)
Time from 30°C to Peak temperature
Exposure
less than 3°C/second
between 300 and 600 seconds
between 240 and 500 seconds
between 30 and 150 seconds
max. 260°C
between 10 and 30 seconds
less than 6°C/second
no greater than 300 seconds
Chip-mount air reflow profile
Temperature / °C
max. 260°C
217°C
max. 300 s
10 ... 30 s
Time / s
30 ... 150 s
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 188a.doc
VI TELEFILTER
Version 1.3
Filter specification
12.05.2005
TFS 188A
5/5
History
Version
Reason of Changes
Name
Date
1.0
- generate development specification
Pfeiffer
10.06.2003
- typical values, matching configuration and terminating impedance added
Pfeiffer
01.08.2003
1.1
- limit for relative attenuation at fN ± 0,06 MHz changed
1.2
- pin connection corrected
Pfeiffer
14.08.2003
1.3
- construction of package changed
- filter characteristic added
- stability characteristics, tape & reel corrected
- air reflow temperature conditions modified
Pfeiffer
12.05.2005
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.