Filename: tfs 161a.doc Version 1.4 VI TELEFILTER 18.07.2006 Filter specification TFS 161A 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedance: * Input: Output: 23 0 °C dBm 660 Ω || -1,6 pF 660 Ω || -1,6 pF Characteristics Remark: The reference level for the relative attenuation arel of the TFS 161A is the minimum of the pass band attenuation amin. The minimum of the pass band attenuation amin is defined as the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB filter attenuation level relative to the insertion loss ae. The nominal frequency fN is fixed at 161,07 MHz without any tolerance. The given values for both the relative attenuation arel and the group delay ripple have to be achieved at the frequencies given below even if the centre frequency fc is shifted due to the temperature coefficient of frequency TCf in the operating temperature range and due to a production tolerance for the centre frequency fc. Data typ. value Insertion loss (reference level) ae Nominal frequency fN Centre frequency fC Passband PB Bandwidth BW 3 dB Relative attenuation fN + 910 OTR Storage temperature range max. 161,074 5 dB 161,070 MHz MHz - min. 100 kHz 65 dB fN ± 10 kHz - TCf ** min 60 - - 20 °C ... + 70°C - - 30 °C ... + 85°C + 25 Frequency inversion temperature Temperature coefficient of frequency dB arel kHz Operating temperature range 3 tolerance / limit -0,036 dB °C ppm/K² *) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team. **) ∆f(Hz) = TCf(ppm/K²) x (T-T0)² x fTo(MHz) Generated: Checked / Approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 161a.doc Version 1.4 VI TELEFILTER 18.07.2006 Filter specification TFS 161A 2/5 0 0 -1 -1 -10 -2 -2 -20 -3 -3 -30 -4 -4 -5 -5 -6 -6 -7 -7 -8 -8 -80 -9 -9 -90 -10 160.98 161 161.02 161.04 161.06 161.08 161.1 161.12 161.14 161.16 -10 0 magnitude in dB magnitude in dB Filter characteristic -40 -50 -60 -70 -100 160.695 160.776 160.857 160.938 161.019 161.1 161.181 161.262 161.343 161.424 161.505 frequency in MHz frequency in MHz Construction and pin connection (All dimensions in mm) 1 2 3 4 5 6 7 8 9 10 TFS 161A ● U29 Date code: U V W ... Ground Input Ground Ground Ground Ground Output Ground Ground Ground Year + week 2006 2007 2008 50 Ω Test circuit 2 L1 C1 7 L2 SAW C2 1, 3, 4, 5, 6, 8, 9, 10 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 161a.doc Version 1.4 VI TELEFILTER 18.07.2006 Filter specification TFS 161A 3/5 Stability characteristics, reliability After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 1 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: three times max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; This filter is RoHS compliant (2002/95/EG, 2005/618/EG) Packing Tape & Reel: IEC 286 – 3, with exception of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: reel of empty components at start: reel of empty components at start including leader: trailer: 2000 min. 300 mm min. 500 mm min. 300 mm Pull Off Direction Tape (all dimensions in mm) W : 16,00 ± 0,3 Po : 4,00 ± 0,1 Do : 1,50 +0,1/-0 E : 1,75 ± 0,10 F : 7,50 ± 0,10 G(min) : 0,60 P2 : 2,00 ± 0,1 P1 : 12,00 ± 0,1 D1(min) : 1,50 +0,1/-0 Ao : 7,60 ± 0,10 Bo : 9,60 ± 0,10 Ct : 13,5 P1 Date Code Po Do P2 W G Ct Bo F G E t Ko Typ PIN Marker D1 Ao W 2 Reel (all dimensions in mm) A : 330 W1 : 16,4 W2(max) : 22,4 N(min) : 50 C : 13,0 A C N W 1 The minimum bending radius is 45 mm. Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 161a.doc Version 1.4 VI TELEFILTER 18.07.2006 Filter specification TFS 161A 4/5 Air reflow temperature conditions Conditions Average ramp-up rate (30°C to 217°C) > 100°C > 150°C > 217°C Peak temperature Time within 5°C of actual peak temperature Cool-down rate (Peak to 50°C) Time from 30°C to Peak temperature Exposure less than 3°C/second between 300 and 600 seconds between 240 and 500 seconds between 30 and 150 seconds max. 260°C between 10 and 30 seconds less than 6°C/second no greater than 300 seconds Chip-mount air reflow profile Temperature / °C max. 260°C 217°C max. 300 s 10 ... 30 s Time / s 30 ... 150 s Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 161a.doc VI TELEFILTER Version 1.4 Filter specification 18.07.2006 TFS 161A 5/5 History Version Reason of Changes Name Date 1.1 Generate Filter specification in actually format. Add “History”. Herrler 24.07.2001 1.2 Correct typo in relative attenuation. Correct reel information. Change matching network. Add typical value for centre frequency. Dr. Wall 17.01.2002 1.3 Correct package drawing. Dr. Wall 16.05.2002 1.4 Correct term and change stability characteristics Add filter characteristic Strehl 18.07.2006 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.