3W DC-DC Converter P3E-Series ● ● ● ● ● ● ● 8 Pin SIL Wide 2:1 input range Up to 1600 VDC isolation MTBF > 2.4 MHours. Continuous short circuit protection Metal case optional Remote control input Model selection guide Typ Single output P3E053R3SC P3E0505SC P3E0512SC P3E0515SC P3E123R3SC P3E1205SC P3E1212SC P3E1215SC P3E243R3SC P3E2405SC P3E2412SC P3E2415SC P3E483R3SC P3E4805SC P3E4812SC P3E4815SC Dual output P3E0505DC P3E0512DC P3E0515DC P3E1205DC P3E1212DC P3E1215DC P3E2405DC P3E2412DC P3E2415DC P3E4805DC P3E4812DC P3E4815DC Input voltage range VDC] Input Current no-load mA] Input current full-load [mA] Output voltage [VDC] Output current min. (1) [mA] Output current max. [mA] Efficiency typ. @ full load [%] Filter inductance L1 [µH] Filter capacity C1 [µF] C-LOad max. [µF] 4.5…9 4.5…9 4.5…9 4.5…9 9…18 9…18 9…18 9…18 18…36 18…36 18…36 18…36 36...72 36...72 36...72 36...72 65 70 75 75 25 15 35 35 15 15 20 20 10 10 15 15 640 800 750 750 260 320 305 305 133 160 156 152 66 82 78 78 3.3 5.0 12.0 15.0 3.3 5.0 12.0 15.0 3.3 5.0 12.0 15.0 3.3 5.0 12.0 15.0 175 150 62,5 50 175 150 62,5 50 175 150 62,5 50 175 150 62,5 50 700 600 250 200 700 600 250 200 700 600 250 200 700 600 250 200 74 76 82 82 76 81 84 84 74 79 82 84 75 78 81 81 6.8 6.8 6.8 6.8 22 22 22 22 22 22 22 22 47 6.8 6.8 6.8 220 220 220 220 100 100 100 100 10 10 10 10 100 100 100 100 2200 1000 470 220 2200 1000 470 220 2200 1000 470 220 2200 1000 470 220 4.5…9 4.5…9 4.5…9 9…18 9…18 9…18 18…36 18…36 18…36 36...72 36...72 36...72 90 90 90 45 45 45 20 20 20 15 15 15 800 760 750 320 308 312 160 154 154 82 80 78 ±5.0 ±12.0 ±15.0 ±5.0 ±12.0 ±15.0 ±5.0 ±12.0 ±15.0 ±5.0 ±12.0 ±15.0 ±75 ±31 ±25 ±75 ±31 ±25 ±75 ±31 ±25 ±75 ±31 ±25 ±300 ±125 ±100 ±300 ±125 ±100 ±300 ±125 ±100 ±300 ±125 ±100 77 81 82 80 83 82 80 83 83 78 80 81 6.8 6.8 6.8 22 22 22 22 22 22 6.8 6.8 6.8 220 220 220 2.2(1210) 2.2(1210) 2.2 (1210) 10 (1210) 10 (1210) 10 (1210) 100 100 100 2 x 470 2 x 220 2 x 100 2 x 470 2 x 220 2 x 100 2 x 470 2 x 220 2 x 100 2 x 470 2 x 220 2 x 100 (1) Operation without load will not damage these devices, but they will not meet all listed parameters. EMI Filter (for EN55022 class A) Input filter components (C1, L1) are used to help meet conducted emissions requirement for the module. These components should be mounted as close as possible to the module; and all leads should be minimized to decrease radiated noise. L1 see table Coiltronics SD3118 series + Vin 2 C1 See table 6 “On” state @ Open or –Vin level 1k 3 Rem.Ctrl. control current “Off” 3~6 mA 1 - Vin + Vout max. C-Load see table 7 - Vout Page 1 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected] 3W DC-DC Converter P3E-Series Part number structure Output power Series P3 3 Watt Input voltage E 05 12 24 48 05 4.5..9 V 9..18 V 18..36 V 36..72 V Output voltage 3R3 3R3 3.3 V 05 5V 7R2 7.2 V 09 9V 12 12 V 15 15 V 18 18 V 24 24 V Outputs S D S single dual Case Remote control M blanc M C plastic metal C Blank control Input without remote control function Page 2 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected] 3W DC-DC Converter P3E-Series Specifications Input Absolute max. voltage for 100 5 V type –0.7..15 VDC ms 12 V type –0.7..36 VDC 24 V type –0.7..50 VDC 48 V type –0.7..100 VDC Input current at standby mode 3 mA max. Filter Capacitors Remote on/off controll on: open or -Vin potential off: 6..3 mA input current (via resistor 1k) Isolation: Rated voltage for 60 s, input / 1600 VDC output (Tested for 3 s) Metal case / input & output 1000 VDC 9 Resistance 10 Ω Capacitance 680 pF, typ. Output Voltage accuracy ±1% 75 mVp-p, max. Ripple and noise (at 20 MHz BW) Short circuit protection Continuous Short circuit restart Automatic Line voltage regulation ± 0.5 % ±1% Output voltage regulation at 25…100% loading Dual output cross regulation ±5% Temperature coefficient ± 0.02 % / °C General Switching frequency 100...650 kHz IEC60950 Safety standard in accordance with EMI (see circuit diagram page 1) Conducted emissions Radiated emissions ESD RS EFT Surge CS PFMF General Switching frequency Safety standard in accordance with Environmental Operating temperatur (ambient) Case temperature Storage temperature Derating Humidity Cooling Physical Dimensions SIP8 Weight Case material standard version Case material metal version Potting material Pin soldering temperature EN55022 class A EN55022 class A IEC61000-4-2 perf. criteria B IEC61000-4-3 perf. criteria A IEC61000-4-4 perf. criteria B IEC61000-4-5 perf. criteria B IEC61000-4-6 perf. criteria A IEC61000-4-8 perf. criteria A 100...650 kHz IEC60950 -40 °C to +71 °C 100 °C, max. -40 °C ... +125 °C See curve Up to 95 %, non-condensing Free-air convection 21.85 x 9.2 x 11,1 mm 4.8 g (Metal version 6.8 g) non-conductive black plastic, UL94-V0 Copper, nickel plated Epoxy UL94-V0 260 C° for 10 s, 1.5 mm distance from body Dimensions Life Support Policy: HY-LINE does not authorize the use of any of its products for use in life support devices or systems without the express written approval of an officer of the Company. Life support systems are devices which support or sustain life, and whose failure to perform, when properly used in accordance with instructions for use provided in the labeling, can be reasonably expected to result in significant injury to the user. Rev: 1.11 f Pin connections Pin 1 2 3 5 6 7 8 Single -V Input +V Input Omitted Omitted +V Output -V Output N.C. Single with RC -V Input +V Input Remote contr. on/off N.C. +V Output -V Output N.C. Dual -V Input +V Input N.C. N.C. +V Output Common -V Output Dual with RC -V Input +V Input Remote contr. on/off N.C. +V Output Common -V Output Page 3 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected]