12W DC-DC Converter P12C-Series ● ● ● ● ● ● ● ● Wide 2:1 Input Range 1600 VDC Isolation MTBF >1 MHours Continuous Short Circuit Protection Efficiency up to 91% 15 mA no load Input Current Soft Start Wide Operation Temperature Range -40...85°C Model selection guide Typ Single output P12C122R5S P12C123R3S P12C1205S P12C1212S P12C1215S P12C242R5S P12C243R3S P12C2405S P12C2412S P12C2415S P12C482R5S P12C483R3S P12C4805S P12C4812S P12C4815S Dual output P12C1212D P12C1215D P12C2412D P12C2415D P12C4812D P12C4815D Input nominal voltage [VDC] Input current full load [mA] Output voltage Output current Efficiency typ. [VDC] [mA] [%] Capacitor Load [µF] 9...18 9...18 9...18 9...18 9...18 18...36 18...36 18...36 18...36 18...36 36...72 36...72 36...72 36...72 36...72 890 1145 1165 1150 1150 445 575 580 575 575 225 285 290 295 290 2.5 3.3 5.0 12.0 15.0 2.5 3.3 5.0 12.0 15.0 2.5 3.3 5.0 12.0 15.0 3500 3500 2400 1000 800 3500 3500 2400 1000 800 3500 3500 2400 1000 800 85 87 89 90 90 85 87 89 90 90 84 88 89 88 89 2000 2000 2000 430 300 2000 2000 2000 430 300 2000 2000 2000 430 300 9...18 9...18 18...36 18...36 36...72 36...72 1150 1135 575 562 295 290 ±12.0 ±15.0 ±12.0 ±15.0 ±12.0 ±15.0 ±500 ±400 ±500 ±400 ±500 ±400 90 91 90 91 88 89 2 x 200 2 x 120 2 x 200 2 x 120 2 x 200 2 x 120 Page 1 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected] 12W DC-DC Converter P12C-Series Specifications Input Filter Pi Network Start up time with R-load 20 ms typ. Remote CTRL on/off, Pin1 On: 3...12V or open input Off: 0...1.2V Standby current 5mA typ Isolation: Rated voltage (for 60 s) 1600 VDC (flash tested 3 s) Resistance 109 Ω Capacitance 1200 pF, typ. Output Voltage accuracy ± 1.2%, max. Voltage balance ± 1% (dual outputs) Cross regulation @ dual outp. ± 5% Temperature coefficient ± 0.02% / °C Ripple and noise 85 mVp-p, max. (at 20 MHz BW) Short circuit protection Indefinite (hiccup), Automatic restart Over current limiting 150% of Iout max. Over voltage protection 2.5V , 3.3V out type 3.9V Z-diode clamping 5V out type 6.2V Z-diode clamping (±) 12V out type (±)15V Z-diode clamping (±) 15V out type (±)18V Z-diode clamping Line voltage regulation ± 0.5%, max. single ± 0.5%, max. Load regulation 0...100% load dual ± 1%, max. Transient recovery time 250µs typ. 3% Transient response drift @ 75%...50%...25% load General Switching frequency Safety Standard EMC Characteristics Radiated Emissions Conducted Emissions ESD RS EFT Surge CS PFMF Environmental Operating temperatur (ambient) Case temperature Storage temperature Derating Humidity Cooling Physical Dimensions Weight Case material Potting material Pin soldering temperature 1.5mm distance from body 330 kHz IEC 60950-1 EN55022 class A EN55022 class A EN61000-4-2 Crit. B EN61000-4-3 Crit. A EN61000-4-4 Crit. B EN61000-4-5 Crit. B EN61000-4-6 Crit. A EN61000-4-8 Crit. A -40 °C to +85 °C 100 °C max. -40 °C to +125 °C see diagram Up to 95%, non-condensing Free-air convection 31.75 x 20.32 x 10.16 mm 18 g Standard, nickel-coated copper metal Epoxy (UL94V-0 rated) 260°C for 10sec 12µH, LD1-120-R Coiltronics + INPUT 22 / 23 14 + OUTPUT Remote ON 330µF KR-Series Nippon Chemicon 1 DC/DC Converter C-Load see table Remote OFF 2/3 16 - INPUT - OUTPUT Page 2 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected] 12W DC-DC Converter P12C-Series Dimensions Pin connections Pin 1 2 3 9 11 14 16 22 23 Single Remote contr. -V Input -V Input Omitted N.C. +V Output -V Output +V Input +V Input Dual Remote contr. -V Input -V Input Common -V Output +V Output Common +V Input +V Input Life Support Policy: HY-LINE does not authorize the use of any of its products for use in life support devices or systems without the express written approval of an officer of the Company. Life support systems are devices which support or sustain life, and whose failure to perform, when properly used in accordance with instructions for use provided in the labeling, can be reasonably expected to result in significant injury to the user. Rev: 12.09 f Page 3 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected]