VECTRON TFS140P

File name: Tfs140P.doc
version 1.3
VI TELEFILTER
1.
Filter specification
02.12.2002
TFS 140 P
1/5
Measurement condition :
45
°C
0
dBm
for input:
for output:
Ambient temperature TA:
Input power level:
Terminating impedances in fc :
2.
50
50
0 pF.
0 pF.
Characteristics :
Remark: Reference level for the relative attenuation arel of the TFS 140 P is the minimum of the pass band attenuation a min. The minimum of
the pass band attenuation amin is defined as the insertion loss a e. The centre frequency fc is the arithmetic mean value of the upper and lower
frequencies at the 6 dB filter attenuation level relative to the insertion loss ae . The temperature coefficient of frequency Tcf is valid both for the
reference frequency fc and the frequency response of the filter in the operating temperature range.
Data
typ. value
tolerance / limit
(Reference level)
ae
25,8
max.
Centre frequency at ambient temperature TA = 45 °C :
fc
140,00
MHz
Centre frequency at room temperature TA = 23 °C :
fc
140,22
MHz
Insertion loss :
Pass band : ( see theoretical
1)
frequency response)
dB
dB
140 ± 0,15
MHz
fC – 9,922 MHz ... fC + 9,922 MHz
PB
Pass band tilt :
0,0
dB/MHz
Deviation from theoretical frequency response at ambient temperature T A = 45 °C
1)
max.
0,01 dB/MHz
(p-p) :
fC - (1-a) fY ... fC + (1-a) fY
or [ fC – 9,922 MHz ... fC + 9,922 MHz ]
± 0,17
dB
± max. 0,2
dB
fC - f Y ... fC + fY
or [ fC + 12,100 MHz ... fC + 12,100 MHz ]
± 0,3
dB
± max. 0,5
dB
min.
40
dB
± max.
2
min.
min.
45
45
dB
dB
max.
15
dBm
Relative attenuation at ambient temperature :
fC ± 15 MHz .... fC ± 120 MHz
arel
60...45
Group delay ( mean value in PB ):
Group delay ripple in PB (p-p):
Deviation from linear phase in PB :
C
Reflected attenuation compared to main signal
Crosstalk attenuation compared to main signal
Nyquist frequency
Roll-off factor
Partitioning factor
fY
a
p
Input power level
-
Temperature coefficient of frequency :
Frequency deviation of f c over temperature :
Operating temperature :
Operable temperature range :
Storage temperature range :
Tcf
1)
27
Theoretical frequency response :
1,3
20
± 1,5
µs
ns
degree
60
52
dB
dB
12,10
0,18
0,5
MHz
- 72 ppm / K
fc(Hz) = Tcf(ppm/K) x (T - TA) x fC (MHz)
+ 45 °C
- 40 °C ... + 85 °C
- 40 °C ... + 85 °C
-
H (x)
( S ( x ))
p
;
1
S (x)
°
1
2
where
f
x
for
,
1
cos
2
0
Generated:
W. Dunzow
Checked/Approved:
Dr. Bert Wall
fC
fY
(x
1
2a
a)
, for
for
x
(1
(1
a)
a)
(1
x
(1
a)
a ),
x
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of
their use or application. No rights under any patent accompany the sale of any such product(s) or information.
File name: Tfs140P.doc
version 1.3
VI TELEFILTER
Filter specification
3. Construction and pin connection :
( all dimensions in mm)
TFS 140 P
02.12.2002
2/5
pin grid 1,91 mm
24.64
TFS
140P
P22
9.00
Date-code:
M
N
P
...
Year+week
2000
2001
2002
...
Date-code
2.62 Max
1.02
1
2
3
4
5
7
6
Pin 1
Pin 10
Pin 6
Pin 5
Pin 2-4, 7-9
11
10
8
2.31
1.91
4.83 x 3.53
4. 50
9
Input
Input RF Return
Output
Output RF Return
Package Ground
1.02
matching networks ( please refer to the application note for further details ) :
1
2
3
4
5
10
9
8
7
6
50
50
Scheme 1.
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of
their use or application. No rights under any patent accompany the sale of any such product(s) or information.
File name: Tfs140P.doc
version 1.3
VI TELEFILTER
Filter specification
02.12.2002
TFS 140 P
3/5
5. Stability characteristics :
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 18 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Change of
temperature:
-55 °C to 125°C / 30 min. each / 10 cycles
DIN IEC 68 part 2 – 14 Test N
4. Resistance to
solder heat (reflow):
reflow possible: twice max.;
for temperature conditions, please refer to the attached "Air reflow temperature conditions"
on page 4;
6. Packing :
Tape & Reel:
DIN IEC 286 - 3, with exception of value for N and minimum bending radius;
tape type II, embossed carrier tape with top cover tape on the upper side;
max. pieces of filters per reel:
reel of empty components at start:
reel of empty components at start including leader:
Trailer
pull off direction
Tape (all dimensions in mm)
W
Po
Do
E
So
P2
P1
D1(min)
Ao
Bo
Ko
t
CT
:
:
:
:
:
:
:
:
:
:
:
:
:
44
4
1,5
1,75
40,4
2
16
2,0
9,3
24,9
2,0
0,35
38,0
± 0,3
± 0,1
+ 0,1
± 0,1
± 0,1
± 0,15
± 0,1
±
±
±
±
±
1000
min 300 mm
min 500 mm
min 300 mm
X-X
Po
t
X
P1
P2
Do
view direction
Ko
0,1
0,1
0,1
0,05
0,1
D1
Ao
X
SPEC-Gurt 0061/ 19X6,5
Q09016:02.001
Jul.10,01
W2
Reel (all dimensions in mm):
A
W1
W2(max)
N(min)
C
:
:
:
:
:
330
44,4 + 2/-0
50,4
100
13,0 +0,5 / -0,2
A
C
N
W1
The minimum bending radius is 45 mm. The mounting surface of the filters faces the bottom side of the embossed carrier tape.
The marking of the filters is able to read if the view is directed on the upper side of the carrier tape in the above shown direction.
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of
their use or application. No rights under any patent accompany the sale of any such product(s) or information.
File name: Tfs140P.doc
version 1.3
VI TELEFILTER
Filter specification
02.12.2002
TFS 140 P
4/5
6. Air reflow temperature conditions :
1st and 2nd air reflow profile
Name:
Temperature:
Time:
pre-heating periods main-heating periods
150 °C - 170 °C
over 200 °C
60 sec. - 90 sec.
20 sec. - 25 sec.
peak temperature
255 °C ± 5 °C
Chip-mount air reflow profile
260
240
220
200
temperature / °C
180
160
140
120
100
80
60
40
20
0
0
20
40
60
80
100
120
140
160
180
200
220
240
time / sec.
Table for temperature vs. time during the air reflow process
Tolerance of temperatures: ± 5 °C
time / sec.
0
10
20
30
40
50
60
70
80
90
100
110
120
130
temperature / °C
23
34
46
60
80
103
121
134
143
150
154
156
158
159
time / sec.
140
150
160
170
180
190
195
200
205
210
215
220
230
240
temperature / °C
160
161
164
170
180
205
230
255
230
205
180
165
140
120
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of
their use or application. No rights under any patent accompany the sale of any such product(s) or information.
File name: Tfs140P.doc
VI TELEFILTER
version 1.3
Filter specification
02.12.2002
TFS 140 P
5/5
7. History :
Version
Reason of Changes
Name
Date
1.0
- generate development specification according to customer requirements.
Dunzow W.
25.03.2002
1.1
- change pin connection according to customer requirements.
Dunzow W.
02.04.2002
- define “ Temperature coefficient of frequency” : Tcf =- 72 ppm / K
- define “ Pass band (PB) ” : fC - (1-a) fY ... fC + (1-a) fY or [ fC – 9,922 MHz ... fC + 9,922 MHz ]
- define “ Deviation from linear phase in PB “ : max. ± 2°
1.2
- correct “Deviation from theoretical frequency response
1)
at ambient temperature TA = 45 °C (p-p) “ :
Dunzow W.
08.04.2002
1.3
- add typical value of filter.
- change tolerance value for insertion loss:
from max. 26 dB to max. 27 dB.
Dunzow W.
02.12.2002
VI TELEFILTER
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of
their use or application. No rights under any patent accompany the sale of any such product(s) or information.