VECTRON TFS433AA

Filename: tfs 433aa.doc
Version 1.0
VI TELEFILTER
04.04.2006
Filter specification
TFS 433AA
1/5
Measurement condition
Ambient temperature:
Input power level:
Terminating impedance: *
Input:
Output:
23
0
°C
dBm
200 Ω || -3,3 pF
200 Ω || -3,3 pF
Characteristics
Remark:
The reference level for the relative attenuation arel of the TFS 433AA is the minimum of the pass band attenuation amin. The minimum of the pass band
attenuation amin is defined as the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB
filter attenuation level relative to the insertion loss ae. The nominal frequency fN is fixed at 433,92 MHz without any tolerance. The given values for both the
relative attenuation arel and the group delay ripple have to be achieved at the frequencies given below even if the centre frequency fc is shifted due to the
temperature coefficient of frequency TCf in the operating temperature range and due to a production tolerance for the centre frequency fc.
Data
typ. value
tolerance / limit
Insertion loss
(reference level)
ae
2,3
Nominal frequency
fN
-
Centre frequency
fC
433,92
MHz
768
826
kHz
kHz
min.
min.
dB
dB
max.
max.
2,0
3,0
dB
dB
dB
dB
dB
dB
dB
dB
dB
min.
min.
min.
min.
min.
min.
min.
45,0
40,0
15,0
10,0
30,0
35,0
45,0
dB
dB
dB
dB
dB
dB
dB
-
max.
10,0
dBm
-
- 25 °C ... + 80°C
dB
dB
±
200,00
fN
fN
fN
fN
fN
fN
fN
+
+
+
+
423,92
19,92
5,92
1,00
8,00
20,00
116,00
3,5
dB
433,92
-
MHz
400
600
kHz
kHz
arel
Relative attenuation
fN
fN
max.
BW
Bandwidth
2
3
dB
kHz
... fN
... fN
±
±
200,00
300,00
kHz
kHz
MHz
MHz
MHz
MHz
MHz
MHz
MHz
…
…
…
…
…
…
…
+
+
+
+
19,92
5,92
1,08
8,00
20,00
116,00
566,00
MHz
MHz
MHz
MHz
MHz
MHz
MHz
fN
fN
fN
fN
fN
fN
fN
Input power level
Operating temperature range
OTR
47
44
22
25
36
46
57
-
Storage temperature range
Frequency inversion temperature
Temperature coefficient of frequency
0,9
1,6
TCf **
- 45 °C ... +120°C
10
°C
-0,031
ppm/K
2
-
*) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference
values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team.
**) ∆fc(Hz) = Tcf(ppm/K²) x (To - TA) ² x fCAT (MHz)
Generated:
Checked / Approved:
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 433aa.doc
Version 1.0
VI TELEFILTER
04.04.2006
Filter specification
TFS 433AA
2/5
Filter characteristic
0
0
-10
-20
-1
-30
-1.5
-40
magnitude in dB
magnitude in dB
10
-0.5
-50
-60
-2
-2.5
0
-3
-70
-3.5
-80
-4
-90
-4.5
-100
163.9
217.9
271.9
325.9
379.9
433.9
487.9
frequency in MHz
541.9
595.9
649.9
703.9
-5
433.6
433.7
433.8
433.9
434
frequency in MHz
434.1
434.2
434.3
434.4
-10
Construction and pin connection
(All dimensions in mm)
7
433AA
● U14
1
SQ 3,81 +0,2/-0,1
5
1
2
3
4
5
6
7
8
Ground
Input
Ground
Ground
Output
Ground
Ground
Ground
Date code:
U
V
W
...
Year + week
2006
2007
2008
3
7
5
0,1
12
0%
0,6
%
d
3
1,78
2,54
1
1,2 Max.
Date code
1,78
50 Ohm Test circuit
2
L1
C1
5
L2
SAW
C2
1, 3, 4, 6, 7, 8
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 433aa.doc
Version 1.0
VI TELEFILTER
04.04.2006
Filter specification
TFS 433AA
3/5
Stability characteristics, reliability
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 1 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Change of
temperature:
4. Resistance to
solder heat (reflow):
-55 °C to 125°C / 30 min. each / 10 cycles
DIN IEC 68 part 2 – 14 Test N
reflow possible: three times max.;
for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4;
This filter is RoHS compliant (2002/95/EG, 2005/618/EG)
Packing
Tape & Reel:
IEC 286 – 3, with exception of value for N and minimum bending radius;
tape type II, embossed carrier tape with top cover tape on the upper side;
max. pieces of filters per reel:
reel of empty components at start:
reel of empty components at start including leader:
trailer:
3000
min. 300 mm
min. 500 mm
min. 300 mm
Pull Off Direction
P1
Tape (all dimensions in mm)
W
: 12,00 ± 0,3
Po
: 4,00 ± 0,1
Do
: 1,50 +0,1/-0
E
: 1,75 ± 0,1
F
: 5,50 ± 0,05
G(min)
: 0,75
P2
: 2,00 ± 0,05
P1
: 8,00 ± 0,1
D1(min)
: 1,50
Ao
: 4,30 ± 0,1
Bo
: 4,30 ± 0,1
Ct
: 9,5 ± 0,1
Date Code
Do
P2
W
G
Ct
Bo
F
G
E
t
Po
Ko
Typ
PIN Marker
D1
Ao
W 2
Reel (all dimensions in mm)
A
: 330
W1
: 12,4 +2/-0
W2(max) : 18,4
N(min)
: 50
C
: 13,0 +0,5/-0,2
C
A
N
W 1
The minimum bending radius is 45 mm.
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 433aa.doc
Version 1.0
VI TELEFILTER
04.04.2006
Filter specification
TFS 433AA
4/5
Air reflow temperature conditions
Conditions
Average ramp-up rate (30°C to 217°C)
> 100°C
> 150°C
> 217°C
Peak temperature
Time within 5°C of actual peak temperature
Cool-down rate (Peak to 50°C)
Time from 30°C to Peak temperature
Exposure
less than 3°C/second
between 300 and 600 seconds
between 240 and 500 seconds
between 30 and 150 seconds
max. 260°C
between 10 and 30 seconds
less than 6°C/second
no greater than 300 seconds
Chip-mount air reflow profile
Temperature / °C
max. 260°C
217°C
max. 300 s
10 ... 30 s
Time / s
30 ... 150 s
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 433aa.doc
VI TELEFILTER
Version 1.0
Filter specification
04.04.2006
TFS 433AA
5/5
History
Version
Reason of Changes
Name
Date
1.0
- Generation of filter specification
Strehl
04.04.2006
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.