Filename: tfs 434d.doc Version 1.2 VI TELEFILTER 24.04.2006 Filter specification TFS 434D 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedance: * Input: Output: 23 0 °C dBm 240 Ω || -2,5 pF 240 Ω || -2,5 pF Characteristics Remark: The nominal frequency fN is fixed at 434,42 MHz. The insertion loss ae is defined as loss value determined at fN. Reference level for the relative attenuation arel of the TFS 434D is the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB filter attenuation level relative to the insertion loss ae. All specified data are met within the operating temperature range. Data typ. value ae = amin Insertion loss (reference level) 1,8 Nominal frequency fN - Centre frequency 3dB fC 434,46 PB - Passband - 0,16 0,18 0,22 fN fN fN fN fN fN fN fN fN fN + + + + + 423,92 19,92 10,42 2,20 1,80 1,00 8,08 66,08 266,08 371,08 dB max. 3,0 434,42 MHz dB MHz fN ± 0,16 MHz arel Relative attenuation fN fN fN tolerance / limit MHz … fN MHz … fN MHz … fN + + + 0,16 0,18 0,22 MHz MHz MHz 0,7 1,2 3,1 dB dB dB max. max. max. 2 3 6 dB dB dB MHz MHz MHz MHz MHz MHz MHz MHz MHz MHz + + + + + 19,92 10,42 2,20 1,80 0,82 8,08 66,08 266,08 371,08 566,08 MHz MHz MHz MHz MHz MHz MHz MHz MHz MHz 55,6 53,6 49,5 54,7 17,8 35,4 43,2 62,3 51,6 65,5 dB dB dB dB dB dB dB dB dB dB min. min. min. min. min. min. min. min. min. min. 52 48 29 26 15 18 40 50 45 60 dB dB dB dB dB dB dB dB dB dB - max. 10 dBm - max. 6 … … … … … … … … … … fN fN fN fN fN fN fN fN fN fN Input power level Permissible DV voltage VDC Operating temperature range OTR Storage temperature range Temperature coefficient of frequency TCf ** - - 40 °C ... + 95°C - - 45 °C ... + 120°C -0,03 ppm/K V 2 *) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team. **) ∆f(Hz) = TCf(ppm/K2) x (T-T0)2 x fcat(MHz). Generated: Checked / Approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 434d.doc Version 1.2 VI TELEFILTER 24.04.2006 Filter specification TFS 434D 2/5 0 0 -10 -0.5 -20 -1 -30 -1.5 -40 magnitude in dB magnitude in dB Filter characteristic -50 -60 -2 -2.5 -3 -70 -3.5 -80 -4 -90 -4.5 -100 300 400 500 600 700 frequency in MHz 800 900 -5 1000 434.1 434.2 434.3 434.4 434.5 frequency in MHz 434.6 434.7 434.8 Construction and pin connection (All dimensions in mm) 7 434D ● U17 1 SQ 3,81 +0,2/-0,1 5 3 1 2 3 4 5 6 7 8 Input RF Return Input Ground Ground Output Output RF Return Ground Ground Date code: U V W ... Year + week 2006 2007 2008 7 5 0,1 12 0% 0,6 % d 3 1,78 2,54 1 1,2 Max. Date code 1,78 50 Ω Test circuit L1 2 1 5 SAW L2 6 3, 4, 7, 8 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 434d.doc Version 1.2 VI TELEFILTER 24.04.2006 Filter specification TFS 434D 3/5 Stability characteristics, reliability After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 1 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: three times max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; This filter is RoHS compliant (2002/95/EG, 2005/618/EG) Packing Tape & Reel: IEC 286 – 3, with exception of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: reel of empty components at start: reel of empty components at start including leader: trailer: 3000 min. 300 mm min. 500 mm min. 300 mm Pull Off Direction Tape (all dimensions in mm) W : 12,00 ± 0,3 Po : 4,00 ± 0,1 Do : 1,50 +0,1/-0 E : 1,75 ± 0,1 F : 5,50 ± 0,05 G(min) : 0,75 P2 : 2,00 ± 0,05 P1 : 8,00 ± 0,1 D1(min) : 1,50 Ao : 4,30 ± 0,1 Bo : 4,30 ± 0,1 Ct : 9,5 ± 0,1 P1 Date Code Po Do P2 W G Ct Bo F G E t Ko Typ PIN Marker D1 Ao W 2 Reel (all dimensions in mm) A : 330 W1 : 12,4 +2/-0 W2(max) : 18,4 N(min) : 50 C : 13,0 +0,5/-0,2 A C N W 1 The minimum bending radius is 45 mm. Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 434d.doc Version 1.2 VI TELEFILTER 24.04.2006 Filter specification TFS 434D 4/5 Air reflow temperature conditions Conditions Average ramp-up rate (30°C to 217°C) > 100°C > 150°C > 217°C Peak temperature Time within 5°C of actual peak temperature Cool-down rate (Peak to 50°C) Time from 30°C to Peak temperature Exposure less than 3°C/second between 300 and 600 seconds between 240 and 500 seconds between 30 and 150 seconds max. 260°C between 10 and 30 seconds less than 6°C/second no greater than 300 seconds Chip-mount air reflow profile Temperature / °C max. 260°C 217°C max. 300 s 10 ... 30 s Time / s 30 ... 150 s Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 434d.doc VI TELEFILTER Version 1.2 Filter specification 24.04.2006 TFS 434D 5/5 History Version Reason of Changes Name Date 1.0 - Generation of development specification Strehl 24.03.2006 1.1 - Change relative attenuation Strehl 28.03.2006 1.2 - Add typical values, add filter characteristic - Generation of filter specification Channaa 24.04.2006 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.