TFS92B

Filename: tfs 92b.doc
Version 1.2
VI TELEFILTER
03.05.2006
Filter specification
TFS 92B
1/5
Measurement condition
Ambient temperature:
Input power level:
Terminating impedance: *
Input:
Output:
23
0
°C
dBm
2530 Ω || -8,1 pF
2380 Ω || -9,4 pF
Characteristics
Remark:
The reference level for the relative attenuation arel of the TFS 92B is the minimum of the pass band attenuation amin. The minimum of the pass band
attenuation amin is defined as the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB
filter attenuation level relative to the insertion loss ae. The temperature coefficient of frequency Tcf is valid for both the reference frequency fc and the
frequency response of the filter in the operating temperature range.
Data
typ. value
Insertion loss
(reference level)
ae
11,3
Nominal frequency
fN
-
Centre frequency
fC
92,01
Amplitude ripple in any 112,5 kHz segment within PB
MHz
fN
MHz
MHz
MHz
MHz
p-p
15
dB
92,0
MHz
±
500
kHz
0,4
dB
max.
0,8
dB
0,2
dB
max.
0,5
dB
arel
Relative attenuation
1,1
1,5
0,3
+
3
fN
Group delay
max.
fN
Pass band ripple
±
±
dB
PB
Passband
fN
fN
tolerance / limit
… fN
±
…
…
…
…
±
±
+
fN
fN
fN
fN
500
1,5
3
3
1
kHz
MHz
MHz
MHz
GHz
at fN
Group delay ripple in any 112,5 kHz segment within PB
Phase linearity in any 112,5 kHz segment within PB
max.
dB
dB
dB
dB
µs
min.
min.
min.
min.
max.
39
40
50
50
4
dB
dB
dB
dB
µs
60
ns
max.
120
ns
deg
max.
5
deg
dB
min.
35
dB
max.
23
dBm**)
1,4
-
Input power level
OTR
Storage temperature range
TCf **
0,8
-
- 40 °C ... + 70°C
-
- 40 °C ... + 100°C
15
Frequency inversion temperature
Temperature coefficient of frequency
dB
38
Triple transit response suppression
Operating temperature range
p-p
0,4
47
48
60
65
2,3
-0,036
°C
ppm/K
dB
2
-
*) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values
only. Should there be additional questions do not hesitate to ask for an application note or contact our design team.
**) This power level is only allowed for short term operation (10% of the life time), the max. input power for continuous operation is max.15dBm only
***) ∆f(Hz) = TCf(ppm/K2) x (T-T0)2 x fTo(MHz)
Generated:
Checked / Approved:
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 92b.doc
Version 1.2
VI TELEFILTER
03.05.2006
Filter specification
TFS 92B
2/5
0
3.06
-1
2.97
-14
-2
2.88
-21
-3
2.79
-28
-4
2.7
-5
2.61
-6
2.52
-49
-7
2.43
-56
-8
2.34
-63
-9
2.25
-35
-42
-70
82
84
86
88
90
92
frequency in MHz
94
96
98
100
-10
91.25
102
91.4
91.55
91.7
91.85
92
92.15
frequency in MHz
92.3
92.45
92.6
delay in µs
0
-7
magnitude in dB
magnitude in dB
Filter characteristic
2.16
92.75
Construction and pin connection
(All dimensions in mm)
10
+0,20
6,50 - 0,10
6
TFS 92B
●
U18
5
Date code
Input
Ground
Ground
Ground
Output
Output
Ground
Ground
Ground
Input
Date code:
U
V
W
...
Year + week
2006
2007
2008
1,02
2,31
1
+0,20
19 - 0,10
2,0 Max.
1
1
2
3
4
5
6
7
8
9
10
1,91
7,62
50 Ohm Test circuit
1
L1
C1
L2
10
5
SAW
L3
C2
6
L4
2, 3, 4, 7, 8, 9
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 92b.doc
Version 1.2
VI TELEFILTER
03.05.2006
Filter specification
TFS 92B
3/5
Stability characteristics, reliability
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 1 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Change of
temperature:
4. Resistance to
solder heat (reflow):
-55 °C to 125°C / 30 min. each / 10 cycles
DIN IEC 68 part 2 – 14 Test N
reflow possible: twice max.;
for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4;
This filter is RoHS compliant (2002/95/EG, 2005/618/EG)
Packing
Tape & Reel:
IEC 286 – 3, with exception of value for N and minimum bending radius;
tape type II, embossed carrier tape with top cover tape on the upper side;
max. pieces of filters per reel:
reel of empty components at start:
reel of empty components at start including leader:
trailer:
Pull Off Direction
Po
Date Code
P1
P2
Ao
Ct
Bo
So
Do
E
t
Ko
W
Tape (all dimensions in mm)
W
: 32,00 ± 0,3
Po
: 4,00 ± 0,1
Do
: 1,50 +0,1/-0
E
: 1,75 ± 0,1
F
: 14,20 ± 0,1
P2
: 2,00 ± 0,1
P1
: 12,00 ± 0,1
D1(min)
: 2,00
Ao
: 7,10 ± 0,1
Bo
: 19,60 ± 0,1
So
: 28,40 ± 0,1
Ct
: 25,5 ± 0,1
2000
min. 300 mm
min. 500 mm
min. 300 mm
Type
Reel (all dimensions in mm)
A
: 330
W1
: 32,4 +2/-0
W2(max) : 38,4
N(min)
: 100
C
: 13,0 +0,5/-0,2
PIN Marker
D1
W2
C
A
N
W1
The minimum bending radius is 45 mm.
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 92b.doc
Version 1.2
VI TELEFILTER
03.05.2006
Filter specification
TFS 92B
4/5
Air reflow temperature conditions
Conditions
Average ramp-up rate (30°C to 217°C)
> 100°C
> 150°C
> 217°C
Peak temperature
Time within 5°C of actual peak temperature
Cool-down rate (Peak to 50°C)
Time from 30°C to Peak temperature
Exposure
less than 3°C/second
between 300 and 600 seconds
between 240 and 500 seconds
between 30 and 150 seconds
max. 260°C
between 10 and 30 seconds
less than 6°C/second
no greater than 300 seconds
Chip-mount air reflow profile
Temperature / °C
max. 260°C
217°C
max. 300 s
10 ... 30 s
Time / s
30 ... 150 s
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 92b.doc
VI TELEFILTER
Version 1.2
Filter specification
03.05.2006
TFS 92B
5/5
History
Version
Reason of Changes
Name
Date
1.0
- Generation of development specification
Strehl
18.10.2005
1.1
- Change relative attenuation
- Change “stability characteristics” to “stability characteristics, reliability”
Strehl
15.11.2005
1.2
- terminating impedances, typical values and filter characteristic added
Pfeiffer
03.05.2006
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.