Filename: tfs 140ae.doc Version 1.2 VI TELEFILTER 08.04.2005 Filter specification TFS 140AE 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedance: Input: Output: 23 0 °C dBm 50 50 Ω Ω Characteristics Remark: The reference level for the relative attenuation arel of the TFS 140AE is the minimum of the pass band attenuation amin. The minimum of the pass band attenuation amin is defined as the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 6 dB filter attenuation level relative to the insertion loss ae. The temperature coefficient of frequency Tcf is valid for both the reference frequency fc and the frequency response of the filter in the operating temperature range. Data typ. value Insertion loss (reference level) ae 30,7 Centre frequency at operating temperature fC - Passband fC ± fY * (1-a) Pass band tilt within PB Relative attenuation dB 32 dB 140 ± 0,25 MHz dB/MHz max. 32 MHz 0,012 dB/MHz dB dB dB dB min. min. min. min. 40 40 50 50 1,2 deg max. ± 0,1 dB max. ± 0,25 dB max. 0,004 arel 50 47 70 58 Deviation from theoretical phase response ∆ϕ Deviation from theoretical frequency response ∆α … fC ± fY * (1-a) fC ± fY * (1-a) … fC ± fY * (1) Nyquist frequency Roll-off factor Partitioning factor fy a p - Group delay at fc 1,1 µs Group delay ripple within PB 9 ns Input power level - Operating temperature range Operable temperature range Storage temperature range Temperature coefficient of frequency max. PB 20 MHz … 115 MHz 165 MHz … 280 MHz Reflected attenuation compared to main signal Crosstalk attenuation compared to main signal fC tolerance / limit OTR TCf ** -72 dB dB dB dB 4,5 deg ± 0,25 dB ± 0,5 dB 20 0,2 1,0 MHz max. 25 ns max. 15 dBm + 45 °C - 45 °C ... + 85°C - 45 °C ... + 85°C ppm/K **) ∆fc(Hz) = Tcf(ppm/K) x (T - To) x fCAT (MHz). Theoretical frequency response : ⎧ P ⎪ H ( x ) = ( S ( x )) ; ⎪ ⎪ ⎧1 ⎪ ⎪ ⎨ ⎛ ⎪ S ( x ) = ⎪ 1 ⋅ ⎜ 1 + cos ⎨ ⎜ ⎪ ⎪2 ⎝ ⎪ ⎪ ⎪ ⎩ 0 ⎩ where , x = f − fC fY for ⎛ π ( x − 1 + a) ⎞⎞ ⎟ ⎟ , for ⎜ ⎟⎟ ⎜ 2a ⎠⎠ ⎝ for x ≤ (1 − a ) (1 − a ) ≤ x ≤ (1 + a ), (1 + a ) ≤ x Generated: Checked / Approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 140ae.doc Version 1.2 VI TELEFILTER 08.04.2005 Filter specification TFS 140AE 2/5 0 1.198 -1 1.186 -20 -2 1.174 -30 -3 1.162 -4 1.15 -5 1.138 -6 1.126 -70 -7 1.114 -80 -8 1.102 -90 -9 1.09 -40 -50 -60 -100 80.5 92.5 104.5 116.5 128.5 140.5 152.5 164.5 176.5 188.5 200.5 frequency in MHz delay in µs 0 -10 magnitude in dB magnitude in dB Filter characteristic 1.078 -10 119.5 123.7 127.9 132.1 136.3 140.5 144.7 148.9 153.1 157.3 161.5 frequency in MHz Construction and pin connection (All dimensions in mm) TFS 140AE ● T15 9 ± 0,2 24,64 ± 0,2 1 10 9 8 7 6 1,02 1,91 ± 0,2 2,31 3,53X4,83 1 2 3 4 5 2,6 Max. Date code 1 2 3 4 5 6 7 8 9 10 Input Ground Ground Ground Output RF Return Output Ground Ground Ground Input RF Return Date code: T U V ... Year + week 2005 2006 2007 Test circuit 1 2 3 4 5 10 9 8 7 6 50 Ω 50 Ω Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 140ae.doc Version 1.2 VI TELEFILTER 08.04.2005 Filter specification TFS 140AE 3/5 Stability characteristics After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 1 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: twice max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; Packing Tape & Reel: IEC 286 – 3, with exeption of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters peer reel: reel of empty components at start: reel of empty components at start including leader: trailer: Pull Off Direc tion Ko Po Da te Code P1 P2 Ao Bo Ct So Do E t W Tape (all dimensions in mm) W : 44,00 ± 0,3 Po : 4,00 ± 0,1 Do : 1,50 +0,1/-0 E : 1,75 ± 0,1 F : 20,20 ± 0,15 P2 : 2,00 ± 0,15 P1 : 16,00 ± 0,1 D1(min) : 2,00 Ao : 9,30 ± 0,1 Bo : 24,90 ± 0,1 So : 40,40 ± 0,1 Ct : 38,0 ± 0,1 1000 min. 300 mm min. 500 mm min. 300 mm Typ e PIN Marker D1 W2 Reel (all dimensions in mm) A : 330 W1 : 44,4 +2/-0 W2(max) : 50,4 N(min) : 100 C : 13,0 +0,5/-0,2 C A N W1 The minimum bending radius is 45 mm. Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 140ae.doc Version 1.2 VI TELEFILTER 08.04.2005 Filter specification TFS 140AE 4/5 Air reflow temperature conditions Conditions Average ramp-up rate (30°C to 217°C) > 100°C > 150°C > 217°C Peak temperature Time within 5°C of actual peak temperature Cool-down rate (Peak to 50°C) Time from 30°C to Peak temperature Exposure less than 3°C/second between 300 and 600 seconds between 240 and 500 seconds between 30 and 150 seconds max. 260°C between 10 and 30 seconds less than 6°C/second no greater than 300 seconds Chip-mount air reflow profile Temperature / °C max. 260°C 217°C max. 300 s 10 ... 30 s Time / s 30 ... 150 s Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 140ae.doc VI TELEFILTER Version 1.2 Filter specification 08.04.2005 TFS 140AE 5/5 History : Version Reason of Changes Name Date 1.0 Generate development specification Noack 25.05.2004 1.1 typical values and filter characteristic added frequency range of passband-stopband transition modified Pfeiffer 05.10.2004 1.2 - air reflow temperature profile modified - set limits of centre frequency at operating temperature Pfeiffer 08.04.2005 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.