Filename: tfs 199e.doc Version 1.5 VI TELEFILTER 07.05.2007 Filter specification TFS 199E 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedance: * Input: Output: 23 0 °C dBm 715 Ω || -5,9 pF 670 Ω || -5,9 pF Characteristics Remark: Reference level for the relative attenuation arel of the TFS 199E is the minimum of the pass band attenuation amin. The minimum of the pass band attenuation amin is defined as the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB filter attenuation level relative to the insertion loss ae. The nominal frequency fN is fixed at 199 MHz without tolerance. The given values for the relative attenuation arel and for the group delay ripple have to be reached at the frequencies given below even if the centre frequency fc is shifted due to the temperature coefficient of frequency TCf in the operating temperature range and due to a production tolerance for the centre frequency fc. Data typ. Value Insertion loss (Reference level) ae 6,5 Nominal frequency fN - Centre frequency fc 199 0,7 dB passband PB Relative attenuation fN ......... fN ± arel fN ± fN ± fN ± fN ± 0,3 0,5 0,6 0,7 MHz ....... MHz ....... MHz ....... MHz ....... dB max. MHz MHz MHz MHz Group delay variation in PB p-p 0,4 7 199 MHz dB MHz fN ± 100 - 0,1 MHz fN ± 0,5 fN ± 0,6 fN ± 0,7 fN ± 80 Limit kHz dB max. 0,7 dB 18 37 39 55 dB dB dB dB min. min. min. min. 10 27 36 45 dB dB dB dB 465 ns max. 700 ns Input power level - max. 18 dBm**) Voltage between any two terminals - max 10 V Frequency inversion temperature (To ) 25 °C Temperature coefficient of frequency Tcf -0,036 ppm/K 2 - Operating temperature range - - 35 °C ... + 85 °C Storage temperature range - - 40 °C …+ 90 °C *) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team **) This power level is only allowed for short term operation (10% of the life time), the max. input power for continuous operation is max.10dBm only Generated: Checked / Approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 199e.doc Version 1.5 VI TELEFILTER 07.05.2007 Filter specification TFS 199E 2/5 0 6.1 -1 5.65 -20 -2 5.2 -30 -3 4.75 -4 4.3 -5 3.85 -6 3.4 -70 -7 2.95 -80 -8 2.5 -90 -9 2.05 -40 -50 -60 -100 198 198.2 198.4 198.6 198.8 199 199.2 199.4 199.6 199.8 frequency in MHz 200 delay in µs 0 -10 magnitude in dB magnitude in dB Filter characteristic 1.6 -10 198.75 198.8 198.85 198.9 198.95 199 199.05 199.1 199.15 199.2 199.25 frequency in MHz Construction and pin connection (All dimensions in mm) 6,5 ±0,2 13,3 ±0,2 10 1,91±0,2 7,62±0,2 5 6 1,8±0,2 1,0±0,2 1 Date code 1,9±0,2 TFS 199E ● V19 1 2 3 4 5 6 7 8 9 10 Input Ground Ground Ground Output Output Ground Ground Ground Input Date code: V W X ... Year + week 2007 2008 2009 200 Ω Test circuit L1 LB-IN 1 SAW C1 1:4 5 L2 LB-OUT C2 6 10 L3 L4 4:1 2,3,4,7,8,9 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 199e.doc Version 1.5 VI TELEFILTER 07.05.2007 Filter specification TFS 199E 3/5 Stability characteristics, reliability After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 1 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: three times max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; This filter is RoHS compliant (2002/95/EG, 2005/618/EG) Packing Tape & Reel: IEC 286 – 3, with exception of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: reel of empty components at start: reel of empty components at start including leader: trailer: 1700 min. 300 mm min. 500 mm min. 300 mm Pull Off Direction Tape (all dimensions in mm) W : 24,00 +0,30/-0,10 Po : 4,00 ± 0,1 Do : 1,50 +0,1/-0 E : 1,75 ± 0,10 F : 11,50 ± 0,10 G(min) : 0,60 P2 : 2,00 ± 0,1 P1 : 12,00 ± 0,1 D1(min) : 1,50 Ao : 7,10 ± 0,10 Bo : 13,90 ± 0,10 Ct : 21,5 ± 0,1 P1 t PIN Marker Po P2 W G Ct Bo F G E Do Ko Date Code Typ D1 Ao W 2 Reel (all dimensions in mm) A : 330 W1 : 24,4 +2/-0 W2(max) : 30,4 N(min) : 60 C : 13,0 +0,5/-0,2 A C N W 1 The minimum bending radius is 45 mm. Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 199e.doc Version 1.5 VI TELEFILTER 07.05.2007 Filter specification TFS 199E 4/5 Air reflow temperature conditions Conditions Average ramp-up rate (30°C to 217°C) > 100°C > 150°C > 217°C Peak temperature Time within 5°C of actual peak temperature Cool-down rate (Peak to 50°C) Time from 30°C to Peak temperature Exposure less than 3°C/second between 300 and 600 seconds between 240 and 500 seconds between 30 and 150 seconds max. 260°C between 10 and 30 seconds less than 6°C/second no greater than 300 seconds Chip-mount air reflow profile Temperature / °C max. 260°C 217°C max. 300 s 10 ... 30 s Time / s 30 ... 150 s Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 199e.doc VI TELEFILTER Version 1.5 Filter specification 07.05.2007 TFS 199E 5/5 History Version Reason of Changes Name Date 1.0 generate specification according to customer requirements Pfeiffer 06.01.2003 1.1 typical values and terminating impedances added Pfeiffer 06.05.2003 1.2 matching configuration changed filter characteristic added Pfeiffer 24.08.2004 1.3 tape and reel direction reversed Steiner 26.09.2005 1.4 change stability characteristics Strehl 14.03.2007 1.5 correct packing Strehl 07.05.2007 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.