1,5W DC-DC Converter P1Q-Series ● ● ● ● ● ● ● ● 2:1 Wide Input Voltage Range Long Life Without Electrolytic Capacitor Low Ripple & Noise Five-Sided Shield Over Current Protection Short Circuit Protection Package 28 x 16 x 7,8 mm Adjustable Output Voltage Model selection guide Typ Input nominal voltage Single output P1Q05S33 P1Q05S05 P1Q05S12 P1Q12S33 P1Q12S05 P1Q12S12 P1Q24S33 P1Q24S05 P1Q24S12 P1Q48S33 P1Q48S05 P1Q48S12 Dual output P1Q05D12 P1Q12D12 P1Q24D12 P1Q48D12 Input current full-load Output voltage Output voltage Range Output current Efficiency typ. Capacitor load max. [VDC] [mA] [VDC] [VDC] [mA] [%] [uF] 4,5…9 4,5…9 4,5…9 9…18 9…18 9…18 18…36 18…36 18…36 36…75 36…75 36…75 426 469 455 167 181 176 84 88 88 42 44 44 3.3 5 12 3.3 5 12 3.3 5 12 3.3 5 12 2,84..3,67 4,3..6 12..15 2,84..3,67 4,3..6 12..15 2,84..3,67 4,3..6 12..15 2,84..3,67 4,3..6 12..15 400 300 125 400 300 125 400 300 125 400 300 125 66 68 70 70 73 75 70 75 75 70 75 75 1650 750 350 1650 750 350 1650 750 350 1650 750 350 4,5…9 9…18 18…36 36…75 450 174 85 43 ±12 ±12 ±12 ±12 ±12..±15 ±12..±15 ±12..±15 ±12..±15 ±60 ±60 ±60 ±60 68 73 75 75 2 x 120 2 x 120 2 x 120 2 x 120 Output voltage adjustment Designation suffix ……S33 ……S05 ……S12 ……D12 VOUT @ pin 5 open 3.3 V 5.0 V 12.0 V ±12.0 V VOUT @ RTrim up 3.3…3.67 V 5.0…6.0 V 12.0…15 V ±12.0…±15 V Trim up Resistor [kΩ] Vout=(3.3*R+36.7)/(R+10) Vout=2.5*(2+2.7)/(R+6.8) Vout=2.5+9.5*(R+10.9)/(R+8.2) Vout=2.5+22*(R+12.7)/(R+10) VOUT @ RTrim down 3.3…2.84 V 5.0…4.3 V Output can be externally trimmed by using the method shown below. 4(3) 5(5) Trim down Resistor [kΩ] Vout=(3.3*R+36.7)/(R+12.92) Vout=2.5*(2+2.7)/(R+6.8) ( ) for dual output TRIM UP TRIM DOWN 6(6) Page 1 of 2 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstraße 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected] 1,5W DC-DC Converter P1Q-Series Specifications Input Voltage range Filter Input surge voltage for 100mS max. Output Power Voltage accuracy Voltage adjustability range Ripple and noise @ 50MHz bandwidth Short circuit protection Over current protection Line voltage regulation Load voltage regulation 10%…100% Temperature coefficient Minimum load 4.5..9, 9..18, 18..36, 36..75VDC LC type 5V type : 15 VDC max. 12V type : 36 VDC max. 24V type : 50 VDC max. 48V type : 100 VDC max. 1,5 W max Single & Dual See table 120mVp-p, max ±2% Continuous, automatic recovery 180 %, typ. 0.2% 0.5% ± 0.02% / °C max. 0% General Efficiency Switching frequency Transient response recovery time Isolation voltage Isolation Resistance Isolation Capacitance Case material Base material MTBF Bellcore TR-NWT-000332 Environmental Operating temperature Storage temperature Cooling Thermal shock Vibration @ no operation Shock Humidity range Physical Dimensions 500µs 650 Fit, @Ta 40°C, 100% 6 stress: 1.5x10 hrs -20 °C to +70 °C with derating -40 °C to +85 °C Nature convection MIL-STD-810D 10..55..10Hz, sweep for 15min, 1.5mm, (9G, X, Y, Z for 2 hrs each) 100G 20% to 95% RH 1.1 x 0.63 x 0.31 inches 28 x 16 x 7.8 mm 8g Weight Dimensions See table 100…1500 kHz @25% load change 500 VDC 6 50 Ω @ 500 VDC 300 pF, typ. Metal None Derating Pin connections PIN 1 2 3 4 5 6 Single + Input - Input No Pin - Output TRIM Input + Output Dual + Input - Input - Output Common + Output TRIM Input Life Support Policy: HY-LINE does not authorize the use of any of its products for use in life support devices or systems without the express written approval of an officer of the Company. Life support systems are devices which support or sustain life, and whose failure to perform, when properly used in accordance with instructions for use provided in the labeling, can be reasonably expected to result in significant injury to the user. Rev: 10 / 2004 f All dimensions in inches (mm) Pin Pitch tolerance ± 0.014 (0.35) Page 2 of 2 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstraße 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected]