P48WG-xxxxE/Z2:1LF Mainzer Straße 151–153 D-55299 Nackenheim Tel. +49 6135 7026-0 Fax: +49 6135 931070 www.peak-electronics.de [email protected] PM8-SERIES Rev.10-2010 20 Watt 2:1 Wide Input Regulated Output Single and Dual Output 1.5 kV DC I/O Isolation 2” x 1” Case Over Voltage Protection The PM8 series is a family of cost effective 20 W, single & dual output DC/DC converters with a wide 2:1 Input. These converters are encapsulated in nickel coated copper 2”x1” case with high performance technology like active clamp, high efficiency operation and output voltage accuracy of ±1% maximum. Precise controlled design provides tight line / load regulation All specifications typical at Ta=25°C, nominal input voltage and full load unless otherwise specified Input Specifications Voltage Range Input Filter Input Reflected Ripple Current¹ Start up Time (Nom. Vin and constant resistive load) 2:1 Wide Input (See Table) PI Type 20 mA pk-pk 20mS, typ. Output Specifications Voltage Accuracy Adjustability (Trim) (Only Single-out Models) Short Circuit Protection Over Current Protection Line Regulation Load Regulation (0% - 100%) Cross Regulation² (dual output) Ripple and Noise (20Mhz bandwidth) Temperature Coefficient Transient Recovery Time3 Transient Response Deviation3 ± 1% ± 10%, max Indefinite (hiccup; Automatic Recovery) 140% of FL, typ. ± 0.5% ± 0.5% (Single-out) ± 1.0% (Dual-out) ± 5% 75 mV pk-pk ± 0.02% / °C 250us, typ. ± 3%, max. General Specifications I/O Isolation Voltage (3 sec.) I/O Isolation Capacitance I/O Isolation Resistance Switching Frequency Humidity Reliability Calculated MTBF (MIL-HDBK-217F) 1500 VDC 1200 pF, typ. 1000 MOhm 330 kHz, typ. 95% rel H > 684 khrs Physical Specifications Case Material Potting Material Weight Nickel Coated Copper Epoxy (UL94V-0 rated) ~ 30g, typ. Environment Specifications Operating Temperature Maximum Case Temperature Storage Temperature Cooling RoHS Conform -40 to +70°C (ambient) 100°C -40 to +125°C Free Air Convection Soldering 260°C, max. (1.5mm from case 10s.) PM8-Series – P48WG-xxxxE/Z2:1LF – Single and Dual Output – 2”x1” - Metal Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 1/4 Selection Guide Single and Dual Output Order # ) ) ) mA A) mA ad ( (mA ad (m 4 ad ( o ) o d L L a C ) o . in Lo ull uF) VD ll L DC ( ( M F o u V t t d ( F e N n n ) a g t t e urre urre olta r Lo y (% rren rren ltag cito ut V ut C ut C enc t Vo i t Cu put Cu a p p p c u u t t t p i f p p u u u In In In O O O Ef Ca SINGLE OUTPUT P48WG-123R3E2:1LF P48WG-1205E2:1LF P48WG-1212E2:1LF P48WG-1215E2:1LF P48WG-243R3E2:1LF P48WG-2405E2:1LF P48WG-2412E2:1LF P48WG-2415E2:1LF P48WG-2418E2:1LF P48WG-483R3E2:1LF P48WG-4805E2:1LF P48WG-4812E2:1LF P48WG-4815E2:1LF 9-18 9-18 9-18 9-18 18-36 18-36 18-36 18-36 18-36 36-72 36-72 36-72 36-72 60 60 30 30 35 35 25 25 25 25 25 15 15 1738 1872 1915 1915 859 926 946 947 957 425 463 473 473 3.3 5 12 15 3.3 5 12 15 18 3.3 5 12 15 0 0 0 0 0 0 0 0 0 0 0 0 0 5500 4000 1670 1330 5500 4000 1670 1330 1110 5500 4000 1670 1330 90 92 90 90 91 93 91 91 87 91 93 91 91 10000 6800 1000 680 10000 6800 1000 680 470 10000 6800 1000 680 DUAL OUTPUT P48WG-1212Z2:1LF P48WG-1215Z2:1LF P48WG-2412Z2:1LF P48WG-2415Z2:1LF P48WG-4812Z2:1LF P48WG-4815Z2:1LF 9-18 9-18 18-36 18-36 36-72 36-72 30 30 30 30 20 20 1937 1937 957 957 478 484 ± 12 ± 15 ± 12 ± 15 ± 12 ± 15 0 0 0 0 0 0 ± 835 ± 665 ± 835 ± 665 ± 835 ± 665 89 89 90 90 90 89 ± 470 ± 330 ± 470 ± 330 ± 470 ± 330 If you need other specifications, please enquire. Notes: PM8-Series – P48WG-xxxxE/Z2:1LF – Single and Dual Output – 2”x1” - Metal Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 2/4 Package / Pinning / Derating 10.16 (0.40) COM +Vout (if Dual) DIA. 1.00 (0.04) 15.24 (0.60) -Vout 3 20.32 (0.80) Modelcode Datecode Vin: Vout: Iout: 4 Bottom View 1 Vin + 25.40 (1.00) All dimensions are typical in millimeters (inches). - Pin diameter: 1.0 +/-0.05 (0.04 +/-0.002) - Pin pitch tolerance: +/-0.35 (+/-0.014) - Case tolerance +/-0.5 (+/-0.02) Specification may change without notice. 5 2 6 15.24 (0.60) 50.80 (2.00) PEAK - 10.16 10.16 2.54 (0.40) (0.40) (0.10) 2.54 (0.10) 5.08 (0.20) min. 10.16 5.08 10.16 (0.40) (0.20) (0.40) 2" x 1" – METAL CASE # 1 2 3 4 5 6 PIN CONNECTIONS SINGLE DUAL +Vin +Vin - Vin - Vin +Vout +Vout Trim Common - Vout - Vout Ctrl. Ctrl. PM8-Series – P48WG-xxxxE/Z2:1LF – Single and Dual Output – 2”x1” - Metal Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 3/4 App Notes 1 = Measured Input reflected ripple current with a simulated source inductance of 12uH. 2 = One load is 25% to 100% load, the other load is 100% load, the output voltage variable rate is within ±5%. 3 = Tested by nominal Vin and 25% load step change (75% - 50% - 25% of Io) 4 = Tested by minimal Vin and constant resistive load. 5 = Input filter components (C1, L) are used to help meet conducted emissions requirement for the module. These components should be mounted as close as possible to the module; all leads should be minimized to decrease radiated noise. 6 = An external filter capacitor is required if the module has to meet EN61000-4-4 and EN61000-4-5 EMC SPECIFICATIONS Part # C1 C2 L P48WG-12xx P48WG-24xx P48WG-48xx 330uF/100V 220uF/100V 220uF/100V / / / 12uH 12uH 12uH Rtrim-up Radiated Emissions Conducted 5 Emissions ESD RS 6 EFT 6 Surge CS PFMF EN 55022 CLASS A EN 55022 CLASS A EN 61000-4-2 EN 61000-4-3 EN 61000-4-4 EN 61000-4-5 EN 61000-4-6 EN 61000-4-8 Perf. Criteria B Perf. Criteria A Perf. Criteria B Perf. Criteria B Perf. Criteria A Perf. Criteria A Rtrim-down 4 3 5 4 External Output Trimming Output can be externally trimmed. (Single output models only!) Over Voltage Protection (Zender diode clamp) 3.3 Vout: Under Input Voltage Lockout (typ.) 3.9 V 12 Vin Models Module ON/OFF 8.6V / 7.9V 5 Vout 6.2 V 24 Vin Models Module ON/OFF 17.8V / 16V 12 Vout 15 V 48 Vin Models Module ON/OFF 33.5V / 30.5V 15 Vout 18 V 18 Vout 20 V Remote ON/OFF Control ± 12 Vout ± 15 V ON: ± 15 Vout ± 18 V OFF: OFF idle current: 3 -12 VDC or open circuit 0 – 1.2 VDC or short circuit PIN2 and PIN6 5mA, typ. Notes: PM8-Series – P48WG-xxxxE/Z2:1LF – Single and Dual Output – 2”x1” - Metal Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 4/4