P20VG-xxxxE/Z2:1LF Mainzer Straße 151–153 D-55299 Nackenheim Tel. +49 6135 7026-0 Fax: +49 6135 931070 www.peak-electronics.de [email protected] PMN-SERIES Rev.11-2012 20 Watt 2:1 Input 1” x 1” Case 1.6 kV DC I/O Isolation Reg. Single and Dual Output Remote ON/OFF Control Continuous Short Circuit Prot. The PMN series is a family of high performance 20W single & dual output DC-DC converters. These are encapsulated in nickel coated copper 1” x 1” case with non conductive base. All specifications typical at Ta=25°C, nominal input voltage and full load unless otherwise specified Input Specifications Voltage Range Input Filter 2:1 Input (see table) Pi-Type Output Specifications Voltage Accuracy Short Circuit Protection Output Voltage Adjustable (trim) Cross Regulation1 (dual output) Line Regulation Load Regulation (0% - 100%) Ripple and Noise (20Mhz bandwidth) Transient Recovery2 Temperature Coefficient ± 1% Indefinite (hiccup, automatic recovery) ± 10%, max. (only single output) ± 5% ± 0.5%, max. ± 0.5%, max. (single) ± 1%, max. (dual) 3.3 & 5.0 V: 75mV pk-pk, max Other modules: 100 mV pk-pk, max. 250 us, typ. ± 0.02% / °C General Specifications Efficiency I/O Isolation Voltage (3 sec.) I/O Isolation Resistance Switching Frequency Humidity Reliability Calculated MTBF (MIL-HDBK-217F) See Table 1600 VDC 1000 MOhm, min. 330 kHz, typ. 95% rel H > 560 khrs Physical Specifications Case Material Weight Nickel Coated Copper ~ 19 g, typ. Environment Specifications Operating Temperature Maximum Case Temperature Storage Temperature Cooling RoHS Conform -40 to +55°C (for 100%) 105°C -40 to +125°C Free Air Convection (10 mm distance required) Soldering 260°C, max. (1.5mm from case 10s.) PMN-Series – P20VG-xxxxE/Z2:1LF – Single and Dual Output – 1”x1” - Metal Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 1/4 Selection Guide Single and Dual Output (If you need other specifications, please enquire) Order # ) A) ) ) mA (mA d (m ad ( (mA a d o ) o d a L L a C ) o )3 ll n. (uF (VD o Lo ull L VDC t Mi t Fu d ( F N e ) n n a t t g e e e o n n a % r r y( rre rre ltag or L Cur Cur Volt ienc t Cu t Vo t Cu acit put put put Inpu Inpu Inpu Out Out Out Effic Cap SINGLE OUTPUT P20VG-123R3E2:1LF P20VG-1205E2:1LF P20VG-1212E2:1LF P20VG-1215E2:1LF P20VG-243R3E2:1LF P20VG-2405E2:1LF P20VG-2412E2:1LF P20VG-2415E2:1LF P20VG-483R3E2:1LF P20VG-4805E2:1LF P20VG-4812E2:1LF P20VG-4815E2:1LF 9-18 9-18 9-18 9-18 18-36 18-36 18-36 18-36 36-75 36-75 36-75 36-75 60 60 30 30 35 35 25 25 25 25 15 15 1439 1852 1873 1873 720 936 936 936 360 468 468 463 3.3 5 12 15 3.3 5 12 15 3.3 5 12 15 0 0 0 0 0 0 0 0 0 0 0 0 4500 4000 1670 1330 4500 4000 1670 1330 4500 4000 1670 1330 86 90 89 89 86 89 89 89 86 89 89 90 7000 5000 850 700 7000 5000 850 700 7000 5000 850 700 DUAL OUTPUT P20VG-1212Z2:1LF P20VG-1215Z2:1LF P20VG-2412Z2:1LF P20VG-2415Z2:1LF P20VG-4812Z2:1LF P20VG-4815Z2:1LF 9-18 9-18 18-36 18-36 36-75 36-75 30 30 30 30 20 20 1873 1873 936 936 468 468 ± 12 ± 15 ± 12 ± 15 ± 12 ± 15 0 0 0 0 0 0 ± 833 ± 667 ± 833 ± 667 ± 833 ± 667 89 89 89 89 89 89 ± 470 ± 330 ± 470 ± 330 ± 470 ± 330 Notes: PMN-Series – P20VG-xxxxE/Z2:1LF – Single and Dual Output – 1”x1” - Metal Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 2/4 Package / Pinning / Derating # 1 2 3 4 5 6 PIN CONNECTION SINGLE DUAL +Vin +Vin - Vin - Vin CTRL CTRL +Vout +Vout Trim Common - Vout - Vout Notes: PMN-Series – P20VG-xxxxE/Z2:1LF – Single and Dual Output – 1”x1” - Metal Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 3/4 App Notes 1 = One load is 25% to 100% load, the other load is 100% load, the output voltage variable rate is within ±5%. 2 = Tested by nominal Vin and 25% load step change (75% - 50% - 25% of Io) 3 = Tested by minimal Vin and constant resistive load. 4 = Input filter meets EN 55022 Class A without external components. 5 = An external filter capacitor is required if the module has to meet EN61000-4-4 and EN61000-4-5 EMC SPECIFICATIONS Radiated Emissions Conducted 4 Emissions ESD RS 5 EFT 5 Surge CS PFMF Rtrim-up EN 55022 CLASS A EN 55022 CLASS A EN 61000-4-2 EN 61000-4-3 EN 61000-4-4 EN 61000-4-5 EN 61000-4-6 EN 61000-4-8 Perf. Criteria A Perf. Criteria A Perf. Criteria A Perf. Criteria A Perf. Criteria A Perf. Criteria A Rtrim-down 5 4 6 5 External Output Trimming Output can be externally trimmed. (Single output models only!) Over Voltage Protection (Zender diode clamp) Under Input Voltage Lockout (typ.) 3.3 Vout: 3.9 V 12 Vin Models Module ON/OFF 8.6V / 7.9V 5 Vout 6.2 V 24 Vin Models Module ON/OFF 17.8V / 15.5V 12 Vout 15 V 48 Vin Models Module ON/OFF 33.5V / 30.5V 15 Vout 18 V ± 12 Vout ± 15 V ± 15 Vout ± 18 V Remote ON/OFF Control ON: OFF: OFF idle current: 3 -12 VDC or open circuit 0 – 1.2 VDC or short circuit PIN2 and PIN3 5mA, typ. Notes: PMN-Series – P20VG-xxxxE/Z2:1LF – Single and Dual Output – 1”x1” - Metal Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 4/4