Filename: tfs 170n.doc Version 1.6 VI TELEFILTER 11.04.2006 Filter specification TFS 170N 1/5 Measurement condition Ambient temperature: Input power level: Terminating impedance: * Input: Output: 23 0 °C dBm 780 Ω || -7,9 pF 760 Ω || -7.9 pF Characteristics Remark: The reference level for the relative attenuation arel of the TFS 170N is the attenuation at nominal frequency fN. The maximum attenuation in the pass band is defined as the insertion loss ae. The nominal frequency fN is fixed at 170,6 MHz without any tolerance or limit. The values of relative attenuation arel are guaranteed for the whole operating temperature range. The frequency shift of the filter in the operating temperature range is included in the production tolerance scheme. Data typ. Value Insertion loss ae Limit 6,6 dB max. 8 dB Nominal frequency fN - Passband PB - fN ± 90 kHz Amplitude ripple in PB p-p 0,4 dB max. 1 dB Relative attenuation fN ± 90 kHz ... fN ± fN ± 0,2 MHz ... fN ± fN ± 0,4 MHz ... fN ± fN ± 0,6 MHz ... fN ± fN ± 0,8 MHz ... fN ± fN ± 1,6 MHz ... fN ± fN ± 3 MHz ... fN ± fN ± 5,8 MHz ... fN ± fN ± 35 MHz ... fN ± fN - 75 MHz ... fN fN + 75 MHz ... 170,6 MHz arel 200 0,4 0,6 0,8 1,6 3 5,8 35 75 170 2 kHz MHz MHz MHz MHz MHz MHz MHz MHz MHz GHz -0,1 2 23 35 45 48 55 60 65 70 70 dB dB dB dB dB dB dB dB dB dB dB min. min. min. min. min. min. min. min. min. min. min. -1 1 13 27 40 43 47 50 45 40 40 dB** dB dB dB dB dB dB dB dB dB dB 17 35 80 83 84 dB dB dB dB dB min. min. min. min. min. 10 20 76 79 80 dB dB dB dB dB Group delay variation in PB 0,25 µs max. 1 µs VSWR in PB 1,5:1 max. 2:1 Input Power Level - max. Time domain response*** 5 µsec 10 µsec 30 µsec 35 µsec ≥ 40 µsec Temperature coefficient of frequency Tcf **** -0,05 ppm/K Frequency inversion temperature T0 35 2 20 dBm - °C - Operating temperature range - - 33 °C .. + 85 Storage temperature range - - 40 °C.. + 125 °C min. dBm IIP3 ***** 36 dBm 30 °C *) The terminating impedances depend on parasites and q-values of matching elements and the board used, and are to be understood as reference values only. Should there be additional questions do not hesitate to ask for an application note or contact our design team. **) reference is max. loss in PB ***) Attenuation values for delays between 5µs and 35µs shall be interpolated linearly. ****)∆f(Hz) = TCf(ppm/K2) x (T-T0)² x fTo(MHz) *****) fin1= 170,5 MHz; fin2= 170,55 MHz; Pin= 0 dBm fmeasurement = 170,6 MHz generated: checked / approved: Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 170n.doc Version 1.6 VI TELEFILTER 11.04.2006 Filter specification TFS 170N 2/5 0 8.79 -1 8.04 -20 -2 7.29 -30 -3 6.54 -4 5.79 -5 5.04 -6 4.29 -70 -7 3.54 -80 -8 2.79 -90 -9 2.04 -40 -50 -60 -100 168.6 169 169.4 169.8 170.2 170.6 171 frequency in MHz 171.4 171.8 172.2 172.6 delay in µs 0 -10 magnitude in dB magnitude in dB Filter characteristic -10 1.29 170.35 170.4 170.45 170.5 170.55 170.6 170.65 170.7 170.75 170.8 170.85 frequency in MHz Construction and pin connection (All dimensions in mm) 6,5 ±0,2 13,3 ±0,2 10 1,0±0,2 1,91±0,2 7,62±0,2 5 6 Date code 1,9±0,2 1 1,8±0,2 TFS 170N ● U15 1 2 3 4 5 6 7 8 9 10 Input RF Return Ground Ground Ground Output Output RF Return Ground Ground Ground Input Date code: U V W ... Year + week 2006 2007 2008 50 Ω Test circuit 10 5 L1 C1 L2 C2 1, 2, 3, 4, 6, 7, 8, 9 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 170n.doc Version 1.6 VI TELEFILTER 11.04.2006 Filter specification TFS 170N 3/5 Stability characteristics, reliability After the following tests the filter shall meet the whole specification: 1. Shock: 500g, 1 ms, half sine wave, 3 shocks each plane; DIN IEC 68 T2 - 27 2. Vibration: 10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans; DIN IEC 68 T2 - 6 3. Change of temperature: 4. Resistance to solder heat (reflow): -55 °C to 125°C / 30 min. each / 10 cycles DIN IEC 68 part 2 – 14 Test N reflow possible: three times max.; for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4; This filter is RoHS compliant (2002/95/EG, 2005/618/EG) Packing Tape & Reel: IEC 286 – 3, with exception of value for N and minimum bending radius; tape type II, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: reel of empty components at start: reel of empty components at start including leader: trailer: 1700 min. 300 mm min. 500 mm min. 300 mm Pull Off Direction Tape (all dimensions in mm) W : 24,00 +0,30/-0,10 Po : 4,00 ± 0,1 Do : 1,50 +0,1/-0 E : 1,75 ± 0,10 F : 11,50 ± 0,10 G(min) : 0,60 P2 : 2,00 ± 0,1 P1 : 12,00 ± 0,1 D1(min) : 1,50 Ao : 7,10 ± 0,10 Bo : 13,90 ± 0,10 Ct : 21,5 ± 0,1 t P1 Date Code Po P2 W G Ct Bo F G E Do Ko Typ PIN Marker D1 Ao W 2 Reel (all dimensions in mm) A : 330 W1 : 24,4 +2/-0 W2(max) : 30,4 N(min) : 60 C : 13,0 +0,5/-0,2 A C N W 1 The minimum bending radius is 45 mm. Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 170n.doc Version 1.6 VI TELEFILTER 11.04.2006 Filter specification TFS 170N 4/5 Air reflow temperature conditions Conditions Average ramp-up rate (30°C to 217°C) > 100°C > 150°C > 217°C Peak temperature Time within 5°C of actual peak temperature Cool-down rate (Peak to 50°C) Time from 30°C to Peak temperature Exposure less than 3°C/second between 300 and 600 seconds between 240 and 500 seconds between 30 and 150 seconds max. 260°C between 10 and 30 seconds less than 6°C/second no greater than 300 seconds Chip-mount air reflow profile Temperature / °C max. 260°C 217°C max. 300 s 10 ... 30 s Time / s 30 ... 150 s Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information. Filename: tfs 170n.doc VI TELEFILTER Version 1.6 Filter specification 11.04.2006 TFS 170N 5/5 History Version Reason of Changes Name Date 1.0 generation of “Development specification” according to customer requirements Pfeiffer 13.07.2004 1.1 package tolerances modified Steiner 16.08.2004 1.2 terminating impedance added (preliminary value) typical value and filter characteristic added definition for insertion loss changed limits for relative attenuation corrected Pfeiffer 17.09.2004 1.3 terminating impedance fixed air reflow temperature conditions modified Pfeiffer 18.10.2004 1.4 limit for maximum input power level fixed to 20 dBm air reflow temperature conditions modified Pfeiffer 04.11.2004 1.5 operating temperature range extended Pfeiffer 31.03.2006 1.6 typical values and more details added for IP3 VSWR typo corrected Pfeiffer 11.04.2006 Tele Filter GmbH Potsdamer Straße 18 D 14 513 TELTOW / Germany Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30 E-Mail: [email protected] VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.