TFS192

Filename: tfs 192.doc
Version 1.1
VI TELEFILTER
01.04.2008
Filter specification
TFS 192
1/5
Measurement condition
Ambient temperature:
Input power level:
Terminating impedance: *
Input:
Output:
23
0
°C
dBm
220 Ω || -18,5 pF
250 Ω || -16,3 pF
Characteristics
Remark:
The reference level for the relative attenuation arel of the TFS 192 is the minimum of the pass band attenuation amin. The minimum of the pass band
attenuation amin is defined as the insertion loss ae. The centre frequency fc is the arithmetic mean value of the upper and lower frequencies at the 3 dB filter
attenuation level relative to the insertion loss ae. The nominal frequency fN is fixed at 192,0 MHz without any tolerance. The given values for both the relative
attenuation arel and the group delay ripple have to be achieved at the frequencies given below even if the centre frequency fc is shifted due to the
temperature coefficient of frequency TCf in the operating temperature range and due to a production tolerance for the centre frequency fc.
Data
typ. value
Insertion loss
(reference level)
ae
Nominal frequency
fN
-
Centre frequency
fC
192
PB
-
Passband
p-p
Pass band ripple
p-p
Amplitude ripple over any 200kHz of the PB
dB
dB
fN
… fN ±
+
+
92
62
6
58
max.
12,0
192,0
MHz
dB
MHz
fN
±
2,75
MHz
0,2
dB
max.
1
dB
0,2
dB
max.
0,4
dB
MHz
MHz
min.
max.
5,5
12
6,3
10,8
Relative attenuation
fN
fN
fN
fN
dB
BW
Bandwidth
1
40
9
tolerance / limit
MHz
MHz
MHz
MHz
…
…
…
…
fN
fN
fN
fN
2,75
+
+
62
6
58
98
arel
MHz
MHz
MHz
MHz
MHz
dB
max.
1
dB
dB
dB
dB
dB
min.
min.
min.
min.
50
40
40
50
dB
dB
dB
dB
µs
max.
1
µs
25
ns
max.
60
ns
18
ns
max.
30
ns
max.
18
dBm
60
45
45
70
0,66
Average group delay within PB
Group delay ripple within PB
0,5
p-p
Group delay ripple over any 200kHz of the PB
p-p
-
Input power level
Operating temperature range
OTR
Storage temperature range
Temperature coefficient of frequency
TCf **
MHz
MHz
-
- 40 °C ... + 85° C
-
- 40 °C ... + 85 °C
-18
ppm/K
-
*) The terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understood as reference values
only. Should there be additional questions do not hesitate to ask for an application note or contact our design team.
**) ∆f(Hz) = TCf(ppm/K) x (T-T0) x fcat(MHz).
Generated:
Checked / Approved:
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 192.doc
Version 1.1
VI TELEFILTER
01.04.2008
Filter specification
TFS 192
2/5
Filter characteristic
0
0
1.082
-7
-1
1.034
-2
0.986
-3
0.938
-4
0.89
-5
0.842
-6
0.794
-7
0.746
-8
0.698
-9
0.65
-14
-21
-35
-42
delay in µs
magnitude in dB
magnitude in dB
-28
-49
-56
-63
-70
102
120
138
156
174
192
210
frequency in MHz
228
246
264
-10
188
282
188.8
189.6
190.4
191.2
192
192.8
frequency in MHz
193.6
194.4
195.2
0.602
196
Construction and pin connection
(All dimensions in mm)
S 192
●
W14
3
Date code
2 Max.
1
Ground
Ground
Output RF Return
Output
Ground
Ground
Ground
Ground
Input RF Return
Input
Ground
Ground
Date code:
W
X
A
...
Year + week
2008
2009
2010
1
5,2 Max.
2,54 ±0,2
7,2 Max.
2,54 ±0,2
1
1
2
3
4
5
6
7
8
9
10
11
12
0,80
50 Ohm Test circuit
L1
10
9
4
SAW
L2
3
C2
C1
1, 2, 5, 6, 7, 8, 11, 12
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 192.doc
Version 1.1
VI TELEFILTER
01.04.2008
Filter specification
TFS 192
3/5
Stability characteristics, reliability
After the following tests the filter shall meet the whole specification:
1. Shock:
500g, 1 ms, half sine wave, 3 shocks each plane;
DIN IEC 68 T2 - 27
2. Vibration:
10 Hz to 500 Hz, 0,35 mm or 5 g respectively, 1 octave per min, 10 cycles per plan, 3 plans;
DIN IEC 68 T2 - 6
3. Change of
temperature:
4. Resistance to
solder heat (reflow):
-55 °C to 125°C / 30 min. each / 10 cycles
DIN IEC 68 part 2 – 14 Test N
reflow possible: three times max.;
for temperature conditions refer to the attached "Air reflow temperature conditions" on page 4;
This filter is RoHS compliant (2002/95/EG, 2005/618/EG)
Packing
Tape & Reel:
IEC 286 – 3, with exception of value for N and minimum bending radius;
tape type II, embossed carrier tape with top cover tape on the upper side;
max. pieces of filters per reel:
reel of empty components at start:
reel of empty components at start including leader:
trailer:
3000
min. 300 mm
min. 500 mm
min. 300 mm
Pull Off Direction
Tape (all dimensions in mm)
W
: 16,00 ± 0,3
Po
: 4,00 ± 0,1
Do
: 1,50 +0,1/-0
E
: 1,75 ± 0,1
F
: 7,50 ± 0,1
G(min)
: 0,60
P2
: 2,00 ± 0,1
P1
: 8,00 ± 0,1
D1(min)
: 1,50
Ao
: 5,50 ± 0,1
Bo
: 7,50 ± 0,1
Ct
: 13,5 ± 0,1
P1
Date Code
Po
Do
P2
W
G
Ct
Bo
F
G
E
t
Ko
Typ
PIN Marker
D1
Ao
W 2
Reel (all dimensions in mm)
A
: 330
W1
: 16,4 +2/-0
W2(max) : 22,4
N(min)
: 50
C
: 13,0 +0,5/-0,2
C
A
N
W 1
The minimum bending radius is 45 mm.
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 192.doc
Version 1.1
VI TELEFILTER
01.04.2008
Filter specification
TFS 192
4/5
Air reflow temperature conditions
Conditions
Average ramp-up rate (30°C to 217°C)
> 100°C
> 150°C
> 217°C
Peak temperature
Time within 5°C of actual peak temperature
Cool-down rate (Peak to 50°C)
Time from 30°C to Peak temperature
Exposure
less than 3°C/second
between 300 and 600 seconds
between 240 and 500 seconds
between 30 and 150 seconds
max. 260°C
between 10 and 30 seconds
less than 6°C/second
no greater than 300 seconds
Chip-mount air reflow profile
Temperature / °C
max.
260°C
217°C
max. 300 s
10 ... 30 s
Time / s
30 ... 150 s
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.
Filename: tfs 192.doc
VI TELEFILTER
Version 1.1
Filter specification
01.04.2008
TFS 192
5/5
History
Version
Reason of Changes
Name
Date
1.0
- Generation of development specification
Strehl
18.06.2007
1.1
- add of terminating impedances, typical values, filter characteristics and matching configuration
- limits of group delay ripple changed
Pfeiffer
01.04.2008
Tele Filter GmbH
Potsdamer Straße 18
D 14 513 TELTOW / Germany
Tel: (+49) 3328 4784-0 / Fax: (+49) 3328 4784-30
E-Mail: [email protected]
VI TELEFILTER reserves the right to make changes to the product(s) and/or information contained herein without notice. No liability is
assumed as a result of their use or application. No rights under any patent accompany the sale of any such product(s) or information.